Recalls in Canada
1 Transport Canada recall for the 2005 BMW HP2 Enduro.
| 2008418 19 Nov 2008 | Lights And Instruments Certain motorcycles fail to comply with the requirements of CMVSS 108 - Lamps, Reflective Devices and Associated Equipment. The front turn signals were install… |
Transport Canada Vehicle Recalls Database · Contains information licensed under the Open Government Licence – Canada
Recalls
BMW IS RECALLING 365 MY 2005-2006 HP2 ENDURO MOTORCYCLES. THE FRONT THREADED FASTENER OF THE PARALEVER LINK MAY NOT HAVE BEEN TIGHTENED TO CORRECT SPECIFICATIONS. IF THE FASTENER WAS NOT TIGHTENED ACCORDING TO SPECIFICATIONS, IT COULD LOOSEN. OVER TIME, IT IS POSSIBLE FOR THE FASTENER TO SEPARATE FROM ITS HOUSING. IF THIS WERE TO OCCUR, THEN THE FINAL DRIVE OF THE MOTORCYCLE WOULD NOT BE PROPERLY SUPPORTED.
Whether a recall was fixed on a particular car is known only to the manufacturer: check the VIN at nhtsa.gov/recalls.
NHTSA recalls · summaries in NHTSA's own words
Service bulletins
What BMW told its dealers about the 2005 BMW HP2 Enduro: known faults, fixes and updates.
| Bulletin | Summary |
|---|---|
| 10249027 | The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle discharged battery complaints. |
| 10205104 | When the rear suspension approaches full compression, the cable ties that secure the rear mudguard to the rear section of the frame can damage the anti-chafing pad of the rear brake hose. |
| 10204667 | One of the following situations can occur when connecting to BN2000 motorcycles: 1. The installed control units cannot be found when reading out with ISTA. 2. Control units initially communicate after connecting to the vehicle, but communication later stops. |
| 10182619 | Discharged Battery Energy Diagnosis Must Be Performed: The electrical system of BMW vehicles has been subject to an ongoing development process over the last few years. This has led to increased demands being placed on the battery. This document covers important information for the dealer on how to handle "discharged battery" complaints. In order to properly repair the vehicle the first time in the workshop, it is very important that the diagnostic test plans are performed to completion, with all results taken into consideration. Without performing the energy diagnosis test plan, the root caus |
| 10135006 | Incorrect tire pressure appears in the instrument cluster. Contamination or obstruction of the RDC sensor. |
| 10037025 | BMW: PROCEDURE FOR DETERMINING AND REPLACING INCANDESCENT AND HALOGEN LIGHT BULBS UNDER WARRANTY. *RM |
| 10033130 | BMW VEHICLES: FUEL LEVEL SENSOR REPAIRS. WHERE IT IS NECESSARY TO REPLACE THE RIGHT OR THE LEFT SIDE FUEL LEVEL SENSOR DUE TO A FAILURE, THE ENTIRE PUMP AND HOUSING OR DELIVERY UNIT (SUCTION JET ASSEMBLY) DO NOT NEED TO BE REPLACED AS WELL. IN SOME CASES, EPC DOES NOT SHOW THAT THE REPAIR KIT IS AVAILABLE SEPARATELY IN THE ILLUSTRATION, BUT IT IS AVAILABLE IN THE PARTS DESCRIPTION. ALL MODELS. NO MODEL YEARS LISTED. *PE |
| 10030825 | BMW MOTORCYCLE: ENGINE FUELS CONTAINING ETHANOL. BMW MOTORRAD HAS NO OBJECTION TO THE USE OF SI ENGINE FUELS CONTAINING UP TO A MAXIMUM OF 10% ETHANOL AND IMPOSES NO WARRANTY RESTRICTIONS. ETHANOL MIXTURES IN PROPORTIONS HIGHER THAN 10% CAN HAVE AN ADVERSE EFFECT ON PERFORMANCE AND CAN RESULT IN DAMAGE TO COMPONENTS THAT COME INTO CONTRACT WITH FUEL. NO WARRANTY CLAIMS WHATSOEVER FOR DAMAGE CAUSED IN THIS WAY WILL BE ACCEPTED. NO MODEL YEARS LISTED. *PE |
NHTSA manufacturer communications (public domain)
NHTSA investigations
Fuel Leak - Motorycle
NHTSA Office of Defects Investigation