Fleetwood Bounder Diesel

FLEETWOOD RV IS RECALLING CERTAIN MODEL YEAR 2005 AND 2006 MOTORHOMES MANUFACTURED BETWEEN JULY 24, 2004 AND MARCH 11, 2005, EQUIPPED WITH NORCOLD MODEL 1200LR, 1200LRIM, AND 1201LRIM REFRIGERATORS WITH SERIAL NUMBERS BETWEEN 1273701 AND 1536607, NON-CONSECUTIVELY. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK. IF A LEAK OCCURS AND THE REFRIGERATOR CONTINUES TO BE OPERATED AFTER SOLUTION CIRCULATION HAS CEASED THE HEAT SOURCE COULD GENERATE VERY HIGH TEMPERATURES. AT SUCH HIGH TEMPERATURES, THE COOLING UNIT COULD RUPTURE.

FLEETWOOD IS RECALLING 311 MY 2008-2009 PROVIDENCE, EXCURSION, EXPEDITION, DISCOVERY AND BOUNDER DIESEL MOTOR HOME. THE BATTERY CABLE MAY BECOME DISLODGED AND COME IN CONTACT WITH THE DRIVER SHAFT CAUSING ENTANGLEMENT OR ABRASION TO THE BATTERY CABLE.

FLEETWOOD IS RECALLING 3,782 MY 2006-2009 PROVIDENCE, EXCURSION, EXPEDITION, DISCOVERY AND BOULDER DIESEL MOTOR HOMES. THE BATTERY CABLE IS ROUTED TOO CLOSE TO A SHARP EDGE LOCATED ON TOP OF A SHELF INSTALLED OVER THE DRIVESHAFT.

FLEETWOOD IS RECALLING 226 MY 2008-2009 AMERICAN ALLEGIANCE, AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION, BOUNDER, BOUNDER DIESEL, DISCOVERY, EXCURSION, EXPEDITION, FIESTA LX, PACE ARROW, PROVIDENCE, REVOLUTION LE, SOUTHWIND, CLASS A MOTOR HOMES, AND ICON, JAMBOREE, JAMBOREE GT, JAMBOREE SPORT, PULSE, TIOGA, AND TIOGA RANGER CLASS C MOTOR HOMES. THESE MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF THE CODE OF FEDERAL REGULATIONS, PART 567, 'CERTIFICATION.' THE OCCUPANT AND CARGO CARRYING CAPACITY WERE CALCULATED INCORRECTLY ALLOWING ADDITIONAL LOAD CARRYING CAPACITY.

DAIMLER TRUCKS IS RECALLING 2,506 MY 2008 XC MOTOR HOME CHASSIS AND THOMAS BUILT HDX SCHOOL AND TRANSIT BUSES EQUIPPED WITH SAF-HOLLAND ADL SERIES REAR SUSPENSIONS. IN SOME INSTANCES THE TRANSVERSE BEAM WAS NOT PROPERLY WELDED WHICH COULD RESULT IN A FAILURE OF THE WELD.

FLEETWOOD IS RECALLING CERTAIN CLASS A GAS AND DIESEL MOTOR HOMES, CLASS C MOTOR HOMES, CONVENTIONAL AND FIFTH WHEEL TRAVEL TRAILERS EQUIPPED WITH NORCOLD REFRIGERATORS. A LOW CYCLE FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH GENERATES THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK.

ON CERTAIN MOTOR HOMES EQUIPPED WITH A FIELD EFFECT TRANSISTOR (FET) BOARD BUILT BY MAGNUM ENERGY, INC., THE CIRCUITRY INSIDE CERTAIN INVERTERS CAN CAUSE AN INOPERATIVE CONDITION RESULTING IN OVERHEATING OF THE INVERTER.

ON CERTAIN MOTOR HOMES, THE SLIDE-OUT ROOM MAY ACTIVATE WHILE TRAVELING, CAUSING THE OVERALL VEHICLE WIDTH TO INCREASE. WATER CAN SHORT OUT THE ELECTRONIC CONTROL RELAY FOR THE SLIDE-OUT ROOM CONTROL MECHANISM.

ON CERTAIN MOTOR HOMES, THE SLIDE-OUT ROOM MAY ACTIVATE WHILE TRAVELING, CAUSING THE OVERALL VEHICLE WIDTH TO INCREASE.

FREIGHTLINER IS RECALLING CERTAIN SCHOOL BUS CHASSIS, HEAVY TRUCKS, VAN CHASSIS, RV MOTORHOME CHASSIS MANUFACTURED FROM JANUARY 5 TO MAY 17, 2007, EQUIPPED WITH AXLE ALLIANCE COMPANY (AAC) FRONT AXLES. DURING THE FRONT AXLE ASSEMBLY, THE FASTENERS THAT ATTACH THE STEERING ARM OR TIE ROD ARMS TO THE SPINDLE MAY BE OVER OR UNDER TIGHTENED.

ON CERTAIN MOTOR HOMES EQUIPPED WITH KWIKEE BRAND ELECTRIC ENTRY STEP BUILT WITH A CONTROL UNIT MANUFACTURED BY AMERICAN TECHNOLOGIES, MAY DEVELOP AN ELECTRICAL SHORT DURING COLD WEATHER, ALLOWING FOR THE POTENTIAL OF THE PLASTIC CASE TO IGNITE.

CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF PART 567, "CERTIFICATION." THE FEDERAL CERTIFICATION TAG MAY BE PRINTED WITH THE INCORRECT GROSS VEHICLE WEIGHT RATING (GVWR) WEIGHT VALUE OF 31,000 POUNDS. THE CORRECT GVWR WEIGHT VALUE IS 28,000 POUNDS. THE SAME WEIGHT ERROR MAY OCCUR ON THE CARGO CARRYING CAPACITY TAG.