Problems owners report
Complaints filed with NHTSA about the 1990 Ford F350, by the system named in each complaint. One complaint can name several.
- Service brakes, hydraulic15
- Fuel system, gasoline9
- Engine and engine cooling9
- Power train5
- Electrical system4
- Tires2
- Suspension2
- Steering1
- Seat belts1
- Visibility1
NHTSA ODI complaints (public domain) · updated 23 Oct 2026 · 6 injuries and 1 deaths reported
Compared with other years
NHTSA ODI complaints by model year
Recalls
THE IGNITION SWITCH COULD EXPERIENCE AN INTERNAL SHORT CIRCUIT.
THE STEEL FUEL RETURN TUBES THAT CONNECT THE FRAME FUEL RETURN LINES WITH THE ENGINE FUEL RAIL CAN CONTACT THE PINCH WELD FLANGE CONNECTING THE DASH PANEL TO THE FLOOR PAN. CONTINUED CONTACT LEADS TO ABRASION OF THE STEEL FUEL RETURN TUBE AND EVENTUALLY RESULTS IN A FUEL LEAK.
A MALFUNCTIONING CHECK VALVE WITHIN THE FUEL PUMP ASSEMBLY CAUSES A PORTION OF THE UNUSED FUEL FROM ONE TANK TO BE RETURNED TO THE SECOND TANK. WHEN THIS OCCURS, THE CAPACITY OF THE SECOND TANK CAN BE EXCEEDED, CAUSING FUEL SPILLAGE.
A REVISED BRAKE LINING NOISE INSULATOR RESULTED IN A DECREASE IN THE THERMAL INSULATION BETWEEN THE BRAKE LINING AND THE FRONT BRAKE CALIPER PISTON. THIS CAUSED GREATER HEAT TRANSFER TO THE CALIPER PISTONS WITH THE POTENTIAL TO OVERHEAT THE BRAKE FLUID AND DIMINISH BRAKE EFFECTIVENESS DURING SEVERE BRAKING CONDITIONS.
UNDER CERTAIN CONDITIONS, THE SNAP RING THAT LOCATES THE PARK GEAR ON THE OUTPUT SHAFT OF THE TRANSMISSION MAY FRACTURE.
INCORRECTLY INSTALLED FUEL LINE CONNECTORS HAVE FUEL SUPPLY AND RETURN LINES CROSSED.
Whether a recall was fixed on a particular car is known only to the manufacturer: check the VIN at nhtsa.gov/recalls.
NHTSA recalls · summaries in NHTSA's own words
Service bulletins
What Ford told its dealers about the 1990 Ford F350: known faults, fixes and updates.
| Bulletin | Summary |
|---|---|
| 623988 | INFORMATION REGARDING TRANSMISSION FLUID USAGE CHARTS. *SLC |
| 623944 | SOME VEHICLES MAY EXHIBIT HEATER CORE LEAKS. *SLC |
| 616522 | SUBJECT REGARDING CONTAMINATION FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM. *TT |
| 613350 | SERVICE TIP INFORMATION REGARDING THE REVERSE CLUTCH PISTON AND PISTON SEAL USAGE. *TT |
| 613341 | EXPERIENCING FRONT END SHIMMY OCCURRING AT VARIOUS DRIVING SPEEDS AND IS USUALLY INDUCED WHEN HITTING BUMPS SUCH AS LARGE POTHOLES OR ROUGH RAILROAD CROSSINGS. *TT |
| 612343 | VEHICLES MAY EXPERIENCE SOLID PARTICLE CONTAMINANTS FROM PRIOR TRANSMISSION CONCERNS OR EXCESS WEAR, MAY BE TRAPPED IN THE TRANSMISSION FLUID COOLING SYSTEM IS NOT PROPERLY FLUSHED, FLUID IN-LINE FILTER KIT. *MJS |
| 612203 | INFORMATION REGARDING THE NEW TRANSMISSION COOLER FLUSHER- SERVICE TIP. *MJS |
| 609737 | TRANSMISSION- E40D/4R100-1989-99-MAIN CONTROLS, SEPARATOR PLATES AND SEPARATOR PLATE GASKETS USAGE CHART. YD |
| 609736 | TRANSMISSION-E40D-NO 2-3 UPSHIFT. SOME VEHICLES MAY EXHIBIT A NO 2-3 UPSHIFT CONDITION. *AK |
| 609538 | FRONT END SHIMMY MAY OCCUR AT VARIOUS DRIVING SPEEDS AND IS USUALLY INDUCED WHEN HITTING BUMPS, SUCH AS LARGE POTHOLES OR ROUGH RAILROAD CROSSINGS. SHIMMY IS NOT ALWAYS VERIFIED DURING ROAD TEST. *AK |
| 6090087 | INFORMATION ON IDENTIFYING NON-APPROVED / ALTERNATE REFRIGERANTS WHICH COULD CAUSE SAFETY, AND PERFORMANCE CONCERNS IF INSTALLED IN FORD A/C SYSTEMS. *TT |
| 6089681 | SUBJECT ON A WIRE HARNESS TERMINAL REPAIR KIT AVAILABLE FOR REPAIRING ELECTRICAL WIRING HARNESSES. *TT |
| 608431 | INFORMATION ON THE NEW FLUSH AND FILL TOOL AVAILABLE THROUGH ROTUNDA. *TT |
| 606460 | EXPERIENCING A WHINE / BUZZ TYPE NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO ON VEHICLES WITH AN IN-TANK ELECTRIC FUEL PUMP. *TT |
| 605721 | SOME VEHICLES MAY DEVELOP "CAVITATION" EROSION IN THE CYLINDER WALL OF THE ENGINE. *TT |
| 605599 | SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62, 628, AND / OR 1728 MAY BE STORED IN MEMORY. *TT |
| 605576 | INFORMATION REGARDING RANDOM HAIRLINE CRACKS, "STAR CRACKING" IN REAR SHEET MOLDING COMPOSITE (SMC) FENDERS - DUAL REAR VEHICLES OPERATING IN SEVERE DUTY CONDITIONS. *TT |
| 605574 | SUBJECT PERTAINING TO RED RUST STAINS ON THE EDGES OF THE BUMPER CENTER VENT AND FOG LAMP OPENINGS. *TT |
| 604059 | FORD MOTOR COMPANY HAS RELEASED A NEW ELECTRICAL GREASE ( F8AZ - 19G208-AA ) TO REDUCE THE POSSIBILITY OF MOISTURE CORROSION AT THE TERMINALS. *YC |
| 601341 | EXPERIENCING A WHINING / BUZZING NOISE IN THE SPEAKERS OF THE ENTERTAINMENT RADIO OR TWO-WAY RADIO. *TT |
| 601312 | INFORMATION ON A BUZZING OR RATTLE NOISE FROM THE EXHAUST SYSTEM. *TT |
| 601290 | INFORMATION ON TIRE COMPANY TELEPHONE NUMBERS FOR CUSTOMER ASSISTANCE. *YC |
| 601280 | SOME VEHICLES MAY EXHIBIT A FLASHING TRANSMISSION CONTROL INDICATOR LAMP (TCIL) AND DIAGNOSTIC TROUBLE CODES (DTCS) 62,628, AND/OR 1728. *YC |
| 601269 | ANNOUNCING THE FORD OEM AIR CONDITIONING RETROFIT KIT AVAILABILITY. *YC |
| 601238 | INFORMATION ON A NEW TRANSMISSION FLUID USAGE CHART. *YC |
NHTSA manufacturer communications (public domain)
NHTSA investigations
DUAL FUEL TANK CROSSFLOW/LEAKAGE
HYDRAULIC BRAKE LINE CRACKS/LEAKS
ALTERNATOR BELT FAILURE
FUEL EXPULSION
FUEL EXPULSION
LOSS OF BRAKE EFFECTIVENES
FUEL EXPULSION
SPARE TIRE FIRES
LOSS OF BRAKE EFFECTIVENES
TRANSMISSION FLUID FIRES
TRNSMSSION PARK GEAR FAIL
NHTSA Office of Defects Investigation