Recalls
20V663000 · Steering28 Oct 2020 · 47,667 vehicles
Daimler Vans USA, LLC (DVUSA) is recalling certain 2015-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The hydraulic power steering return line hoses may detach at their connection points under certain operating conditions, causing hydraulic fluid to leak.
Whether a recall was fixed on a particular car is known only to the manufacturer: check the VIN at nhtsa.gov/recalls.
NHTSA recalls · summaries in NHTSA's own words
Service bulletins
What Freightliner told its dealers about the 2016 Freightliner Sprinter 4500: known faults, fixes and updates.
| Bulletin | Summary |
|---|---|
| 11011223 | SMOG/Emissions Test fail due to one or more Readiness Monitors not set Complaint: The vehicle has failed the State Emissions Certification because one or more of the OBDII readiness monitors are not completely set. Cause: One or more of the following Readiness Monitors are not fully set within XENTRY: Misfire Monitoring - Injection System Fuel System Monitoring - Injection System, Fuel System, EGR Valve, O2 Sensor NMHC Catalyst Monitoring - NMHC/Diesel Oxidation Catalyst NOx Aftertreatment Monitoring - SCR Catalyst System Boost Pressure System Monitoring - Turbocharger, Charge Air System Exh |
| 11001114 | Complaint A: The engine is jolting/bucking between 1700 and 1900 rpm. Complaint B: One or more mechanical related fault codes for EGR Valve stored in CDI control unit, with possible Check Engine Light. Review list of mechanical fault codes in table below. NOTE: If one or more electrical related fault codes for EGR Valve are also present in CDI, utilize Complaint C. Review list of electrical fault codes PDF document in attachments. Complaint C: One or more electrical related fault codes for EGR Valve stored in CDI control unit, with possible Check Engine Light. Review list of electrical fault c |
| 10228805 | Problem: Vehicle fails smog test Cause In the event the Engine Control Module (CDI) detects a fault with the Water Pump Short Circuit to Battery diagnostic, Fault Code P260312 and/or P260315 may set and prevent the readiness monitor from running. Even following a successful repair and/or clearing the Fault Code(s), the readiness monitor remains deactivated and self-healing is not possible. This deactivation may prevent the vehicle from passing state emissions inspection and SMOG Test and is only resolvable by installing new engine control unit software. Remedy 1. Perform XENTRY Qui |
| 10228611 | Software Update - Water Pump Diagnostics |
| 10227139 | SMOG Test will not complete successfully. NOTE: Customers may come to dealership as instructed by ISP (Independent Service Provider) based on instructions from a TSB (Technical Service Bulletin). Access to the TSBs can be found via https://www.obdclearinghouse.com/ or by viewing the TSBs in the attachments area of this LI. Cause In the event the Engine Control Module (CDI) detects a fault with the Water Pump Short Circuit to Battery diagnostic, Fault Code P260312 and/or P260315 may set and prevent the readiness monitor from running. Even following a successful repair and/or clearing th |
| 10212902 | Modification to the emission control system. |
| 10212897 | Modification to the emission control system. |
| 10181196 | Mercedes-Benz USA, LLC (?MBUSA?) has entered into an agreement with the United States Department of Justice (DOJ), the Environmental Protection Agency (EPA), the California Air Resources Board (CARB), and the California Attorney General?s Office (CA AG) regarding the emission control system in certain MercedesBenz diesel vehicles. As part of this agreement, MBUSA will offer field measures referred to as the Approved Emission Modification (?AEM?) for the affected vehicles. As a result, certain vehicles covered under this notification cannot be sold or caused to be sold, or leased or cause to |
NHTSA manufacturer communications (public domain)
NHTSA investigations
EA21002 · Air bags:frontal:driver side:inflator moduleopened 17 Sept 2021
Desiccated Air Bag Inflator Rupture
NHTSA Office of Defects Investigation