Recalls
NAVISTAR IS RECALLING 51,588 HEAVY TRUCKS, COMMERCIAL BUSES AND SCHOOL BUSES MANUFACTURED BETWEEN NOVEMBER 21, 2000 AND MAY 21, 2008, EQUIPPED WITH ONE OR MORE REMOTE POWER MODULES. THE POTTING MATERIAL THAT ENCAPSULATES THE CIRCUIT BOARD OF THE VEHICLE'S REMOTE POWER MODULE MAY NOT SUFFICIENTLY SEAL THE CIRCUIT BOARD FROM WATER AND CONTAMINATION INTRUSION. IF THE ENCAPSULATION IS COMPROMISED, WATER AND CONTAMINANTS MAY CAUSE AN INTERNAL ELECTRICAL SHORT, POSSIBLY RESULTING IN A FIRE.
Whether a recall was fixed on a particular car is known only to the manufacturer: check the VIN at nhtsa.gov/recalls.
NHTSA recalls · summaries in NHTSA's own words
Service bulletins
What IC told its dealers about the 2002 IC HC: known faults, fixes and updates.
| Bulletin | Summary |
|---|---|
| 10251409 | Suggested alignment target values when performing a vehicle axle alignment. |
| 10246231 | J1939 Data Link Source Address Information |
| 10243610 | How to request a horsepower quote; all International and Cummins engines |
| 10234000 | Starter diagnostics and warranty claim procedure for all engines and all chassis EXCLUDING vehicles equipped with PSI engines or Cummins ISB engine with Allison transmissions |
| 10227455 | J1939 Data link source address information |
| 10222490 | Pico Scope CCOS (Crankcase Separator Test) |
| 10219330 | PicoScope Test One Channel RCT |
| 10219325 | PicoScope Test Resistance and Ohmmeter |
| 10219319 | PicoScope Test for Datalink (CAN) Health Shorts & opens |
| 10219314 | PicoScope Test - Battery Loss of Charge - Parasitic Draw Test |
| 10209487 | Calculating pulses per mile (speedometer setting); only models equipped with International engines |
| 10208431 | J1939 Data Link Source Address Information |
| 10204139 | Power Steering Diagnostics Flow / Pressure Specifications For Power Steering Gears and Power Steering Pumps |
| 10204137 | J1939 Data Link Troubleshooting |
| 10201758 | Engine Oil Capacities. All International electronic engines 1994 to present and Cummins ISB, ISM, or ISX engines |
| 10199915 | General wheel speed sensor troubleshooting |
| 10198708 | Aftertreatment Clamp Corrosion; Single Can Aftertreatment Systems |
| 10179294 | Driveline Information Center and Troubleshooting Procedures |
| 10179289 | Repair Procedures for Vehicles Struck by Lightning |
| 10177073 | This article is for adding additional protection to the driver's area of the bus to help mitigate the transmission of germs. |
| 10173025 | Cleaning and Disinfecting Trucks and Buses |
| 10172045 | J1939 Data Link Troubleshooting |
| 10165643 | Oil Capacities; All Electronic International Engines 1994 - Present. Cummins ISB, ISM & ISX |
| 10163416 | Suspension Lean Diagnostics; All models |
| 10162034 | J1939 Data Link Source Address Information |
NHTSA manufacturer communications (public domain)
NHTSA investigations
SCHOOL BUS STALLING
NHTSA Office of Defects Investigation