Recalls
Prevost Car (US) Inc. (Prevost) is recalling certain 2005-2024 X3-45, 2017-2019 and 2021-2023 X3-45 Commuter, 2006-2007, 2014, and 2018 H3-41, 2005-2020 and 2022-2024 H3-45, and 2019 H3-45 VIP buses equipped with a wheelchair lift. The wheelchair platform bridging device may be too steep, which can cause the wheelchair to become unstable. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard numbers 403, "Platform Lift Devices" and 404, "Platform Lift Installations."
Prevost Car (US) Inc. (Prevost) is recalling certain 2014 and 2018 H3-41, 2013-2024 H3-45, 2012-2024 X3-45, and 2017-2023 X3-45 Commuter vehicles. The red beacon lighting on the Threshold Warning System (TWS) may not be bright enough. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 403, "Platform Lift Systems."
Prevost Car (US) Inc. (Prevost) is recalling certain 2021 and 2023 X3-45 Commuter buses. The bolt securing the passenger seat recline mechanism may loosen and disengage, resulting in an unsecured seat back.
Prevost Cars (US) Inc. (Prevost) is recalling certain 2021-2023 X3-45 Commuter buses. The foldable passenger seat frames may have been improperly welded. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 210, "Seat Belt Assembly Anchorages."
Prevost Cars (US) Inc. (Prevost) is recalling certain 2021-2023 X3-45 Commuter busses. The foldable passenger seat cushion bolts may be loose and could fall out, allowing the seat cushion to detach from the seat frame.
Prevost Car (US) Inc. (Prevost) is recalling certain 2021-2023 Prevost X3-45 Commuter motorcoaches. The driver's seat is equipped with a Type 1 seat belt instead of the correct Type 2 seat belt. As such, these vehicles fail to comply with the requirements of the Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Prevost Car (US) Inc. (Prevost) is recalling certain 2021-2023 X3-45 commuter buses. The retention pin securing the passenger seat recline mechanism could fail, causing the mechanism to collapse, and result in a loose backrest. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 210, "Seat Belt Assembly Anchorages."
Prevost Car (US) Inc. (Prevost) is recalling certain 2010-2023 H3-45, H3-45 VIP, X3-45, X3-45 Com, and X3-45 VIP vehicles. In the event of the alternator front bearing seizing, the alternator belt may continue to operate, causing the bearing to overheat.
Whether a recall was fixed on a particular car is known only to the manufacturer: check the VIN at nhtsa.gov/recalls.
NHTSA recalls · summaries in NHTSA's own words
Service bulletins
What Prevost told its dealers about the 2023 Prevost X3-45 Commuter: known faults, fixes and updates.
| Bulletin | Summary |
|---|---|
| 11003159 | Sway bar collars improvement. Revision A : Add front sway bar support replacement and change bolts lenght. |
| 10248275 | SWAY BAR COLLARS IMPROVEMENT |
| 10235258 | Motion Sensor Relocation |
| 10233625 | On the vehicles affected by this bulletin, the Vehicle Emission Control Information label must be replaced. Revision: B - Causal part changed, was 010352, becomes 85152363. No impact on procedure or parts involved. |
| 10233618 | On the vehicles affected by this bulletin, install a driver seat orange belt in replacement of the black one. |
| 10233616 | On the vehicles affected by this bulletin, the steering dampers and related hardware must be inspected and may need to be replaced by new improved units. |
| 10232208 | Driver's barrier installation instructions |
| 10231093 | STEERING GATEWAY. Revision B - PIN 2 and 10 were inverted on connector A139 |
| 10228667 | Air Tanks Draining Sequence. Revision: B - General Update |
| 10226928 | Air Tanks Draining Sequence. Revision: A - Erroneous Secondary & Accessory tanks location. |
| 10226927 | Air Tanks Draining Sequence |
| 10225569 | On the vehicles affected by this bulletin, the positive terminal (main power cable) may not be fully tightened at the back some the alternators. |
| 10222383 | TAG AXLE AIR SPRING RUBBING ISSUE INSTALLATION OF NON-RETURN VALVE |
| 10222380 | TAG AXLE HUB FLANGE - ALTERNATE CAP SCREW |
| 10219026 | Wheelchair lift system sliding door adjustment |
| 10214937 | X3 SERIES ENVIROCARE - IONS AIR SANITIZER |
NHTSA manufacturer communications (public domain)
NHTSA investigations
Alternator Front Bearing Failure
NHTSA Office of Defects Investigation