Compared with other years
NHTSA ODI complaints by model year
Recalls
Spartan Motors USA (Spartan) is recalling certain 2010-2014 K2 and K3 motor home chassis and Gladiator emergency response chassis cabs. A component within the starter motor may break, potentially resulting in the starter motor overheating or drawing excessive current.
Spartan Motors USA (Spartan) is recalling certain 2011-2017 Gladiator, 2016-2017 MetroStar, 2012-2018 K2, 2011-2018 K3, 2017-2018 K4, and 2011-2017 MM vehicles. The ball joints on the independent front suspension (IFS) modules can loosen and separate, leading to a partial loss of steering.
Spartan Motor Chassis, Inc. (Spartan) is recalling certain model year 2009-2012 MM, 2011-2014 K2, and 2010-2012 K3 motor home chassis. Due to contact with the steering relay rod, the ABS modulator valve may fracture resulting in air not being applied to the affected wheel end.
Spartan Motors, Inc. (Spartan) is recalling certain model year 2012-2013 K2, K3, and MM motor homes manufactured March 2, 2012, through July 30, 2012 and equipped with a 1660 independent front suspension supplied by Reyco Granning. The motor homes may have incorrect wheel bearings installed in the front suspension.
SPARTAN IS RECALLING CERTAIN MODEL YEAR 2012 K2 AND MG CHASSIS MANUFACTURED FROM DECEMBER 15, 2011, THROUGH JANUARY 31, 2012, AND EQUIPPED WITH 3030 BRAKE CHAMBERS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 121, AIR BRAKE SYSTEMS BECAUSE THEY DO NOT MEET THE PARK BRAKE AND DRAW BAR REQUIREMENTS.
SPARTAN IS RECALLING CERTAIN MODEL YEAR 2011-2012 K2 RECREATIONAL VEHICLES MANUFACTURED FROM SEPTEMBER 30, 2010, THROUGH NOVEMBER 22, 2011, RATED AT 52,000 LBS AND EQUIPPED WITH 3030 BRAKE CHAMBERS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 121, AIR BRAKE SYSTEMS BECAUSE THEY DO NOT MEET THE PARK BRAKE AND DRAW BAR REQUIREMENTS.
SPARTAN IS RECALLING CERTAIN MODEL YEAR 2010, 2011, AND 2012 RECREATIONAL VEHICLES, MODELS MM, K2, K3, BUS, FURION, GLADIATOR, AND METRO STAR, MANUFACTURED FROM SEPTEMBER 29, 2010, THROUGH JUNE 20, 2011, EQUIPPED WITH A CUMMINS ISB, ISC, ISL, OR ISX DIESEL ENGINE. THE V-BAND CLAMP ASSEMBLY, PART NUMBERS Q187684, Q187685, AND Q187686, USED TO CONNECT THE INLET AND OUTLET CONE SECTIONS TO THE DIESEL OXIDATION CATALYST (DOC)/DIESEL PARTICULATE FILTER (DPF) INCLUDE A T-BOLT WHICH CAN FRACTURE AND FAIL WHEN SUBJECTED TO STRESS OR LOAD. A FRACTURE OR FAILURE OF THE T-BOLT MAY CAUSE THE CLAMP TO LOOSEN AND THE INLET OR OUTLET SECTIONS ATTACHED TO THE DOC/DPF HOUSING TO DISCONNECT.
Spartan Motors Chassis, Inc. (Spartan Chassis) is recalling certain 2011 SU and 2011 through 2012 model year MM, K2, and K3 recreational vehicle chassis manufactured from January 28, 2011, through June 28, 2011, equipped with air gauges supplied by Ametek. An incorrect value may have been used in the formula for calculating the sweep angle of the dial. This may have resulted in the accuracy of the gauge varying as much as eleven percent from the cutout pressure as opposed to the maximum allowable of +/- seven percent. Consequently, these chassis fail to conform to the requirements of Federal Motor Vehicle Safety Standard No. 121, "Air Brake Systems."
Whether a recall was fixed on a particular car is known only to the manufacturer: check the VIN at nhtsa.gov/recalls.
NHTSA recalls · summaries in NHTSA's own words
Service bulletins
What Spartan told its dealers about the 2012 Spartan K2: known faults, fixes and updates.
| Bulletin | Summary |
|---|---|
| 10249131 | This service bulletin is about the power steering fluid level sensor could exhibit leaks where sensor seals against power steering reservoir and provides instructions on replacing current power steering level sensor with improved sensor design. |
| 10133514 | The service bulletin precribes a solution for certain washers installed on the suspension system that may be subject to breaking/cracking. |
| 10127590 | This service bulletin provides instructions on how to apply appropriate torque to rear suspension fasteners to resolve popping noises. |
| 10058839 | SPARTAN MOTORS: SOME MOTOR HOME CHASSIS ARE EXPERIENCING A FUEL TANK DEFORMITY AND FUEL SENDER BY SHOWING LESS FUEL ON FUEL GAUGE THAN IN FUEL TANK AND WOULD NEED TO HAVE FUEL SENDER FLOAT ARM ADJUSTMENT. MODEL 2002-15 MM, K3, K2, NVS. *PE |
| 10053744 | SPARTAN: ON CERTAIN MOTORHOME CHASSIS, THE HADLEY AIR LEVEL SYSTEM MODULE MAY NOT BE ACTIVATED BY THE INTERFACE MODULE AND NEED TO CHANGE CONSTANT BATTERY CIRCUIT OF MODULE TO SWITCH POWER SOURCE (ACCESSORY CIRCUIT). MODELS 2007-2013 K2, K3. *PE |
NHTSA manufacturer communications (public domain)
NHTSA investigations
TSE Brakes, Inc. Hill Hold Requirements
NHTSA Office of Defects Investigation