Complaints by model year
Each bar is one model year. The most recent years are still collecting complaints.
NHTSA ODI complaints (public domain) · updated 23 Oct 2026
Year by year
| Model year | Complaints | Recalls |
|---|---|---|
| 2005 | 0 | 2 |
| 2004 | 0 | 3 |
| 2003 | 1 | 3 |
| 2002 | 0 | 2 |
| 2001 | 0 | 2 |
| 2000 | 1 | 3 |
| 1999 | 2 | 3 |
| 1998 | 3 | 2 |
| 1997 | 4 | 2 |
| 1996 | 1 | 0 |
A model year gets its own page when it has enough data for at least three sections
Most common problems
- Structure4
- Tires2
- Equipment2
- Electrical system2
- Service brakes, hydraulic1
- Fuel system, other1
- Exterior lighting1
- Engine and engine cooling1
NHTSA ODI complaints, all model years
Recalls
8 campaigns cover the Ultrasport.
DAMON IS RECALLING 4,677 MY 2004-2006 CHALLENGER, DAYBREAK, INTRUDER, MY 2004-2005 ESCAPER, ULTRASPORT, AND MY 2005 ASTORIA AND ASTORIA WALDORF MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
DAMON IS RECALLING 804 MY 1999 INTRUDER, ULTRASPORT, AND ESCAPER MOTOR HOMES EQUIPPED WITH NORCOLD REFRIGERATORS. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK.
CERTAIN TRAVEL TRAILERS AND MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE MOTOR HOMES WERE BUILT WITHOUT THE RED REAR REFLEX REFLECTORS AND SOME MOTOR HOMES WERE BUILT WITHOUT THE SIDE REAR RED REFLEX REFLECTORS.
DURING THE WINTERIZATION PROCESS ON CERTAIN MOTOR HOMES FROM NOVEMBER 5, 2002 THROUGH JANUARY 6, 2003, THE RV ANTIFREEZE USED MAY HAVE BEEN CONTAMINATED WITH ENGINE ANTIFREEZE.
VEHICLE DESCRIPTION: CERTAIN MOTOR HOMES BUILT ON DODGE VAN CHASSIS AND EQUIPPED WITH SAFETY BELT ASSEMBLIES PRODUCED BY AM-SAFE BETWEEN JANUARY 28 AND AUGUST 15, 2000. ON SOME SEAT BELTS, THE BUCKLE AND CONNECTOR MAY UNLATCH DURING A COLLISION.
VEHICLE DESCRIPTION: MOTOR HOMES AND TRAVEL TRAILERS EQUIPPED WITH NORCOLD REFRIGERATOR COOLING UNITS MODEL NUMBERS N841, N821, N641, AND N621. THESE REFRIGERATORS CAN EXPERIENCE A COOLING SYSTEM LEAK CAUSED BY OPERATION IN THE AC ELECTRIC MODE. IF A LEAK OCCURS, THE COOLING PERFORMANCE OF THE REFRIGERATOR WILL DETERIORATE, REQUIRING IMMEDIATE REPLACEMENT OF THE COOLING UNIT.
VEHICLE DESCRIPTION: CLASS A AND C MOTOR HOMES. THE HARDWARE USED TO SECURE THE LIQUID PROPANE (LP) TANK WAS NOT TIGHTENED PROPERLY.
NHTSA recalls