Complaints by model year
Each bar is one model year. The most recent years are still collecting complaints.
NHTSA ODI complaints (public domain) · updated 23 Oct 2026
Year by year
| Model year | Complaints | Recalls |
|---|---|---|
| 2002 | 0 | 0 |
| 2001 | 0 | 0 |
| 2000 | 0 | 0 |
| 1999 | 0 | 0 |
| 1998 | 0 | 0 |
| 1997 | 0 | 0 |
| 1996 | 0 | 2 |
| 1995 | 2 | 1 |
| 1994 | 6 | 1 |
| 1993 | 5 | 1 |
| 1992 | 1 | 1 |
| 1991 | 0 | 1 |
| 1990 | 0 | 1 |
| 1989 | 2 | 1 |
| 1987 | 0 | 1 |
| 1986 | 0 | 1 |
| 1984 | 0 | 1 |
| 1982 | 0 | 1 |
A model year gets its own page when it has enough data for at least three sections
Most common problems
- Service brakes, hydraulic4
- Air bags4
- Seat belts3
- Power train3
- Fuel system, gasoline2
- Electrical system2
- Engine and engine cooling1
NHTSA ODI complaints, all model years
Fuel consumption by year
Official Canadian test results for 1 model years, best variant per year. Combined consumption ranges from 17.0 L/100 km.
| Year | Variant | City | Highway | Combined |
|---|---|---|---|---|
| 1995 | G25 Rally · Van: Cargo · Regular gasoline | 18.3 | 15.4 | 17.0 |
Litres per 100 km. Natural Resources Canada, Fuel consumption ratings (open.canada.ca) · Open Government Licence – Canada
Recalls
10 campaigns cover the G25.
THE STEERING LINKAGE ASSEMBY CONTAINS A RELAY ROD TAPERED-STUD ATTACHMENT NUT THAT WAS NOT TORQUED TO PROPER SPECIFICATIONS.
WATER INTRUSION INTO THE KICK PANEL AREAS IN FRONT OF BOTH THE DRIVER AND PASSENGER DOORS CAN CAUSE A CORROSION PATH BETWEEN THE BATTERY FEED AND THE ELECTRICAL GROUND.
BOTH THE SUPPLEMENTAL INFLATABLE RESTRAINT (SIR) CAUTION LABEL AND AN ENGINE START LABEL WERE INSTALLED ON THE SAME SIDE OF THE DRIVER'S SUN VISOR. THIS DOES NOT COMPLY WITH FMVSS NO. 208, "OCCUPANT CRASH PROTECTION."
THE TRANSFORMER USED TO POWER THE NEON CENTER LIGHTBEAM CAN OVERHEAT AND CATCH ON FIRE.
THE BRAKE PEDAL ASSEMBLY HAS A PUSHROD PIN THAT IS TOO SMALL AND IT IS INSTALLED IN THE WRONG POSITION, CAUSING AN INCREASED BRAKE PEDAL RATIO AND A DECREASED MASTER CYLINDER STROKE.
SEAT BACK OF THE REAR BENCH SEAT MAY BREAK AWAY FROM THE SEAT CUSHION IN AN ACCIDENT.
FUEL TANK LOWER FILLER PIPE MAY CONTAIN SMALL HOLES AT SOME SPOT WELDS USED TO ATTACH A MOUNTING BRACKET.
THE PUSH PULL HEADLIGHT SWITCH MAY HAVE ELECTRICAL CONTACTS WHICH ALLOW AN INTERMITTENT HEADLIGHT CIRCUIT CAUSING HEADLIGHT TO FLICKER OR SUDDENLY GO OUT. CONSEQUENCE OF DEFECT: SUDDEN LOSS OF THE HEADLIGHTS UNDER SEVERE WEATHER OR NIGHTTIME DRIVING CONDITIONS COULD REDUCE DRIVER VISIBILITY WHICH MIGHT RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING.
PLASTIC PLUG LOCATED ON TOP OF THE FRONT AIR CONDITIONER WAS NOT REMOVED DURING ASSEMBLY. THIS DEFECT DISRUPTS NORMAL OPERATION OF EVAPORATOR BLOWER HOUSING.
THE LOCKING SCREW THAT RETAINS THE PINION SHAFT IN PLACE IN THE DIFFERENTIAL COULD COME LOOSE. THE PINION SHAFT TURNS THE GEARS INSIDE THE DIFFERENTIAL THAT ROTATE THE DRIVE AXLES AND REAR WHEELS. IF THE LOCKING SCREW COMES LOOSE, IT COULD DAMAGE OTHER COMPONENTS OR JAM IN THE GEARS. IF THE PINION SHAFT COMES LOOSE, THE REAR WHEELS MAY NO LONGER POWER THE VEHICLE.
NHTSA recalls