Fatal crashes in the US
From 2020 to 2023, 10 2020 337 vehicles were involved in crashes on US public roads in which someone died; 2 people died inside them, and 1 of the vehicles rolled over. This is a count, not a crash rate: it grows with the number of cars on the road.
NHTSA Fatality Analysis Reporting System (FARS), crash years 2020–2023 (public domain)
New York safety inspections
At its first New York inspection the 2020 Peterbilt 337 failed the safety check 0.00% of the time — 100% less often than the average 2020 passenger car (1.18%). Median odometer at inspection: 79,239 miles.
NY DMV Vehicle Inspections (vezn-fmmk), initial inspections since Aug 2021 · how we count
Recalls in Canada
2 Transport Canada recalls for the 2020 Peterbilt 337.
| 2022210 25 Apr 2022 | Steering Issue: On certain trucks, the fasteners that attach the steer arm to the steering knuckle may fail. If this happens, the steer arm could separate from the ste… |
| 2021323 26 May 2021 | Fuel System Issue: On certain trucks, the fuel rail assembly could develop a leak. Note: This recall only affects trucks equipped with a Cummins L9 or ISX12 diesel engi… |
Transport Canada Vehicle Recalls Database · Contains information licensed under the Open Government Licence – Canada
Recalls
PACCAR Incorporated (PACCAR) is recalling certain 2018-2020 Kenworth T270, T370, T440, T470, T660, T680, T880, T800, W900, W990; and 2018-2020 Peterbilt 330, 337, 348, 365, 367, 389, 520, 567, and 579 vehicles. The Dana D-Series axle steer arm fasteners that attach the steering arm to the steering knuckle may fail.
PACCAR Incorporated (PACCAR) is recalling certain 2018-2021 Peterbilt 337, 348, 365, 367, 520, 567, Kenworth T270, T370, T440, T470, T800 and T880 vehicles. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak.
PACCAR Incorporated (PACCAR) is recalling certain 2019-2020 Peterbilt 337 and 348 vehicles. An incorrectly located weld in the steering shaft may crack and cause the lower shaft within the steering column to separate from the mating yoke.
Whether a recall was fixed on a particular car is known only to the manufacturer: check the VIN at nhtsa.gov/recalls.
NHTSA recalls · summaries in NHTSA's own words
Service bulletins
What Peterbilt told its dealers about the 2020 Peterbilt 337: known faults, fixes and updates.
| Bulletin | Summary |
|---|---|
| 11010926 | Info Only Unnecessary starter replacements can result from customer complaints regarding engine starting issues. A new Starter Troubleshooting Guide has been created to provide a comprehensive list of starting system checks, which should reduce unnecessary starter replacements and associated warranty claims. Engine starting system warranty claims now require a completed Starter Checklist, a Battery Pack Midtronics Report, and a Cable Drop Midtronics Report. Claims filed without these documents may be denied. |
| 11005516 | Fix As Fail The height control valve (HCV) rod on vehicles with low air leaf suspensions is prone to toggling over center during rough road conditions. With full suspension articulation, HCV bracket flexes and toggles over center the HCV linkage, which results in either deflated airbags or makes them unable to inflate. Fix-as-fail start date is 07/30/2024. |
| 10232162 | Fix As Fail Chassis that were manufactured with certain battery cable routing brackets may experience rubbing or chafing of the battery cables. |
| 10225578 | Info Only - PACCAR is introducing Over-the-Air (OTA) software updates for engine MY17 and newer chassis equipped with Cummins X15, X12, ISX12, ISX12N, L9N, PX-7, and PX-9 engines The technology will leverage the existing Remote Diagnostic cs hardware to deliver secure software updates remotely. This will reduce downtime and save on maintenance costs for eligible vehicles. |
| 10222269 | Fix-As-Fail On certain chassis with Low Air Leaf Suspension or Low-Low Air Leaf Suspension, the Height Control Valve (HCV) arm may be rubbing on other components when the bend in the arm is facing outboard. Flipping the bend in the HCV arm inboard prevents the rub. |
| 10219235 | The service information for Bendix Air Dryer maintenance is being updated to include new procedures. |
| 10209699 | Fix-As-Fail A hill start assist (HSA) valve plumbing revision eliminates ice buildup in the HSA valve exhaust in cold weather. |
| 10208758 | Due to major data carriers phasing out 3G networks, chassis currently utilizing first generation Peoplenet Mobile Gateway (PMG001) will experience severe 3G service degradation as early as January of 2022. Chassis currently utilizing 3G antennas as a primary antenna may experience this degradation. |
| 10201965 | Fix-As-Fail Due to undersupply issues, only a limited supply of Diesel Exhaust Fluid (DEF) sensors are available. As a temporary solution, after PACCAR confirms a DEF sensor is not available, a temporary software update will allow a vehicle to continue operation with a failed DEF sensor by disabling the DEF sensor diagnostics. |
| 10201956 | Information Only - Rear axle Quarter Fenders with less than two inches of clearance between the top of the quarter fender and the bottom of the trailer/equipment are susceptible to damage. The lack of clearance could result in cracked/broken quarter fenders or complete separation if undetected or un-remedied. |
| 10199985 | Fix-as-Fail: Radio does not mute when truck with auto trans is placed in reverse. Software flash resolves issue. |
| 10198809 | Safety Recall Cummins Fuel Rail Leak NHTSA ID: 21V391 / TC: 2021-323, Cummins Recall: C2423.Cummins PX9 and ISX12 fuel rails may leak around a sealing washer, potentially resulting in fuel leaks.Undetected prolonged diesel fuel spray in the presence of an ignition source may increase the risk of fire. |
| 10188550 | Information Only Windshield washer pumps have a high No Trouble Found rate. Washer pumps may fail to spray due to a clogged filter. |
| 10186168 | SmartNav 2.0 Hardware retrofit for quality validation and vehicle validation units. |
| 10182219 | Fix as Fail: Peterbilt has introduced an improved mounting bracket for low mount air tanks for vehicles built between January 01, 2017 and July 06, 2020. Torsional vibration may stress the currently-installed brackets and cause them to fail near the bottom of the frame rail. |
| 10180726 | Information only: In 2020, Peterbilt and Kenworth began using the same M10, M12, M16, and M20 frame fasteners on all vehicles. Torque specifications for these fasteners are different from previous fasteners. |
| 10177935 | Fix-As-Fail - Bendix New-Gen Lightweight Steer Axle Drum Brake Spider Cracking |
| 10177021 | Information Only: This bulletin provides dealers with a battery warranty quick reference guide to ensure the appropriate tests for battery warranty are performed in order to prevent battery warranty claims filed with incorrect or incomplete information. |
| 10177019 | Fix as Fail: For all conventional models, except 387/587, equipped with Side-of-Cab (SOC) exhaust and built from 03/6/2006 to 1/20/2020, the clamps that secure the SOC exhaust stacks may not be tightened properly. This may allow the exhaust stack to rotate and contact the cab or sleeper. |
| 10176033 | Information only: Hendrickson Softek front axle maintenance intervals and requirements. |
| 10173205 | Information Only: Proper jump-starting voltage will eliminate high voltage related issues and equipment damage. |
| 10169787 | Information Only - Vehicles built with NAMUX software from 2013 to present may experience accuracy issues with the tachometer. The issue can be temporarily resolved using any one of the included procedures. |
| 10168703 | Information Only: This bulletin provides guidance for repairing an air-conditioning system after internal failure of the A/C compressor. |
| 10165592 | Information: Chassis built after 01/11/2016 with hydraulic brakes were provided with a jumper harness in the glove box or tool box that is required when programming the ABS. If this harness is no longer in the vehicle, order from PACCAR Parts. |
| 10165583 | Information Only This bulletin provides information about the California Air Resources Board (CARB) Periodic Smoke Inspection Program (PSIP) and Heavy Duty Vehicle Inspection Program (HDVIP). |
NHTSA manufacturer communications (public domain)