Recalls
ON CERTAIN FIRE CHASSIS EQUIPPED WITH HARRISON HYDRA-GEN GENERATORS. THE TUBING CONNECTING THE SOFT START TO THE GENERATOR PUMP CAN BREAK AWAY FROM THE FITTING AND SPRAY HYDRAULIC FLUID ONTO THE EXHAUST.
VEHICLE DESCRIPTION: FIRE APPARATUS ON CERTAIN COMMERCIAL CHASSIS WITH OPTIONS FOR FUEL TANK STEP COVERS. CERTAIN VEHICLES WERE BUILT WITHOUT DRAIN HOLES IN THE ALUMINUM STEP LOCATED BELOW THE FUEL FILL OPENING.
VEHICLE DESCRIPTION: FIRE TRUCKS EQUIPPED WITH OSHKOSH ALL-STEER ALL-WHEEL STEERING SYSTEM. THE REAR WHEELS OF A FIRE ENGINE CAN TURN UNINTENTIONALLY IF THE ALL-WHEEL STEERING SYSTEM KEY IS ON AND MOISTURE PENETRATES TO THE WIRE THAT CONNECTS THE STEERING SENSOR TO THE ELECTRONIC CONTROL UNIT (ECU). IT WAS DISCOVERED THAT THE INSULATION COVERING THE WIRES BETWEEN THE SENSOR AND THE ECU HAD BEEN NICKED DURING TIME OF ASSEMBLY. OVER TIME, THE NICK IN THE INSULATION ALLOWED MOISTURE TO PENETRATE TO THE ACTUAL WIRE.
Whether a recall was fixed on a particular car is known only to the manufacturer: check the VIN at nhtsa.gov/recalls.
NHTSA recalls · summaries in NHTSA's own words
Service bulletins
What Pierce told its dealers about the 2000 Pierce Fire Truck: known faults, fixes and updates.
| Bulletin | Summary |
|---|---|
| 11011818 | This bulletin is to support the dealer network when replacing a ASL 360 ECU that requires programming on the truck. |
| 11011817 | Software update for fault codes on Command Zone display: This software update may help remove ambiguity between active and inactive engine error codes shown on the Command Zone display. |
| 11008386 | All Roto Rays are warranted to the purchaser for twenty-four months from the date of service against defects in material or workmanship. During the warranty period products found to be defective will be repaired or replaced (at Roto Rays option) without charge. The defective light must be returned to Roto Rays, INC., 722 Park Ave., Herndon, VA 20170. The light will be returned to the purchaser prepaid. |
| 10036912 | CATERPILLAR: SEE DOCUMENT SEARCH BUTTON FOR OWNER LETTER. NEW SOFTWARE NEEDS TO BE INSTALLED ON CERTAIN C9 ENGINES INSTALLED IN PIERCE FIRE TRUCKS THAT ARE EQUIPPED WITH A TWO STAGE WATER PUMP. THE EXISTING SOFTWARE COULD CAUSE THE ENGINE RPMS TO SURGE WHILE IN PTO (PUMP MODE). *PE |
NHTSA manufacturer communications (public domain)
NHTSA investigations
ALL WHEEL STEERING MALFUNCTION
NHTSA Office of Defects Investigation