Complaints by model year
Each bar is one model year. The most recent years are still collecting complaints.
NHTSA ODI complaints (public domain) · updated 23 Oct 2026
Year by year
| Model year | Complaints | Recalls |
|---|---|---|
| 2005 | 0 | 1 |
| 2004 | 3 | 3 |
| 2003 | 1 | 2 |
| 2002 | 2 | 3 |
| 2001 | 0 | 3 |
| 2000 | 3 | 6 |
| 1999 | 0 | 5 |
| 1998 | 0 | 3 |
| 1997 | 1 | 2 |
A model year gets its own page when it has enough data for at least three sections
Most common problems
- Service brakes, hydraulic4
- Suspension3
- Service brakes2
- Power train2
- Equipment2
- Electrical system2
- Wheels1
- Visibility1
NHTSA ODI complaints, all model years
Recalls
12 campaigns cover the Sahara.
ON CERTAIN MOTOR HOMES, FIFTH WHEEL AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION, THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
CERTAIN MOTOR HOMES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, 'AIR BRAKE SYSTEMS.' TWO DELIVERY LINES ON THE BRAKE SYSTEM WERE INSTALLED INCORRECTLY.
ON CERTAIN CLASS A MOTOR HOMES, THE SPACER PLATE UNDER THE TRAILING ARMS HAD A TRANSVERSE WELD WHICH CREATES A HEAT RISER AND CAUSE THE TRAILING ARMS TO CRACK.
ON CERTAIN MOTORHOMES, THE I-BEAM LEAF IMITATOR IN THE FRONT AXLE SUSPENSION COULD CRACK AND BREAK DUE TO AN INADEQUATE WELDING PROCESS.
CERTAIN 36', 38', AND 40' MOTOR HOMES FAIL TO COMPLY WITH REQUIREMENTS OF PART 567, "CERTIFICATION." THE REAR PSI STATES 85 OR 115 LBS. THE CORRECT REAR PSI IS 95 LBS.
ON CERTAIN MOTORHOMES, FIFTH WHEELS AND TRAVEL TRAILERS EQUIPPED WITH NORCOLD REFRIGERATOR COOLING UNITS MODEL NUMBERS 1200LR AND 1200RIM, THESE REFRIGERATORS CAN EXPERIENCE LOW CYCLE FATIGUE FAILURE WHICH CAN LEAD TO THE LIQUID SOLUTION SLOWLY LEAKING FROM THE SEALED, PRESSURIZED COOLING UNIT THROUGH A SMALL CRACK.
ON CERTAIN MOTOR HOMES, THE BRAKE ASSEMBLIES EXHIBIT ELEVATED TEMPERATURES THAT CAN LEAD TO CATASTROPHIC DETERIORATION OF THE WHEEL END COMPONENTS SUCH AS BEARINGS, RACES, SPINDLES, KNUCKLES, SEALS, HUBS, ROTORS, PATCH BOLTS, CALIPERS, BRAKE PADS, AND ABS SENSORS.
ON CERTAIN MOTOR HOMES EQUIPPED WITH ELECTRONIC THROTTLE CONTROL/ACCELERATOR PEDALS SUPPLIED BY WILLIAMS CONTROLS INDUSTRIES, THE WELD ATTACHING THE CLEVIS TO THE PLATE HAS INSUFFICIENT PENETRATION AND COULD ALLOW THE CLEVIS TO SEPARATE FROM THE PLATE.
VEHICLE DESCRIPTION: MOTOR HOMES EQUIPPED WITH MERITOR WABCO PHASE 1, D-VERSION ANTILOCK BRAKE SYSTEM (ABS), FAIL TO COMPLY TO THE REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." AN INTERNAL DIAGNOSTIC SYSTEM IN THE ABS MAY NOT DETECT AN EXTREME WHEEL SPEED SENSOR AIR GAP. SUCH A CONDITION COULD POSSIBLY OCCUR DURING (1) ORIGINAL ASSEMBLY OR (2) SUBSEQUENT WHEEL END SERVICE.
VEHICLE DESCRIPTION: CERTAIN MOTOR HOMES BUILT ON DODGE VAN CHASSIS AND EQUIPPED WITH SAFETY BELT ASSEMBLIES PRODUCED BY AM-SAFE BETWEEN JANUARY 28 AND AUGUST 15, 2000. ON SOME SEAT BELTS, THE BUCKLE AND CONNECTOR MAY UNLATCH DURING A COLLISION.
VEHICLE DESCRIPTION: CERTAIN CLASS A MOTOR HOMES EQUIPPED WITH SAFETY BELT ASSEMBLIES BUILT BY AM-SAFE. ON SOME SEAT BELTS, THE BUCKLE AND CONNECTOR MAY UNLATCH DURING A COLLISION.
VEHICLE DESCRIPTION: 1999 AND 2000 MOTOR HOMES MANUFACTURED BETWEEN APRIL 2 AND NOVEMBER 20, 1999, AND EQUIPPED WITH ABS SYSTEMS WITH BRAKE WIRING HARNESS PART #2505168. THE ELECTRICAL CONNECTOR WHICH CONNECTS TO THE MODULATOR WAS MIS-WIRED CAUSING THE ANTI-LOCK BRAKE MODULATOR TO REACT IMPROPERLY WHILE REGULATING HYDRAULIC PRESSURE TO THE APPROPRIATE WHEEL.
NHTSA recalls