Problems owners report
Complaints filed with NHTSA about the 2004 Winnebago Sightseer, by the system named in each complaint. One complaint can name several.
- Service brakes, hydraulic4
- Engine and engine cooling2
- Suspension2
- Equipment2
- Fuel system, other1
- Service brakes1
- Parking brake1
NHTSA ODI complaints (public domain) · updated 23 Oct 2026 · 0 injuries and 0 deaths reported
Compared with other years
NHTSA ODI complaints by model year
Recalls in Canada
8 Transport Canada recalls for the 2004 Winnebago Sightseer.
| 2010368 26 Oct 2010 | Accessories Certain refrigerators used in Recreational Vehicles (RVs) contain either a sensing algorithm or a thermal switch to interrupt power when it detects high tempera… |
| 2009194 24 Jun 2009 | Brakes On certain motorhomes, the brake calipers may stick in the applied position. This can result in abnormal heat generation at the wheel end which, if undetected,… |
| 2006304 14 Nov 2006 | Fuel System On certain motorhomes equipped with Workhorse Custom Chassis, the engine fuel rail pulse damper retainer clip may fracture, resulting in inadequate retention of… |
| 2006305 14 Nov 2006 | Lights And Instruments Certain motorhomes fail to comply with the requirements of CMVSS 101 and 105. Incorrect software programmed into the instrument panel cluster may not allow act… |
| 2004445 21 Dec 2004 | Fuel System Certain motorhomes may have insufficient clearance in the area where the fuel line and frame cross member intersect. The cross member may wear into the fuel li… |
| 2004399 15 Nov 2004 | Seats And Restraints On certain vehicles, the seat belts do not meet the strength requirements of CMVSS 209. In the event of a crash, the seat belt buckle could release, leaving th… |
| 2003350 29 Dec 2003 | Other On certain recreational vehicles equipped with a Samsung microwave oven, an electrical short can occur in the microwave oven's membrane panel keypad causing the… |
| 2003166 3 Jul 2003 | Other On certain vehicles, the flame on the cooking range may be forced downward over the burner or flame outage may occur when the cooking range and furnace are oper… |
Transport Canada Vehicle Recalls Database · Contains information licensed under the Open Government Licence – Canada
Recalls
WINNEBAGO IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.
WINNEBAGO IS RECALLING VEHICLES EQUIPPED WITH AXLES THAT INCLUDE BOSH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.
ON CERTAIN MOTOR HOMES BUILT ON A 20,700 GVWR OR GREATER WORKHORSE CHASSIS, THERE MAY NOT BE SUFFICIENT CLEARANCE IN THE AREA WHERE THE FUEL LINE CROSSES THE FRAME CROSS MEMBER.
CERTAIN SEAT BELT BUCKLES ON SOME MOTOR HOMES FAIL TO CONFORM TO THE LOAD REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
ON CERTAIN MOTOR HOMES EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE UNITS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.
ON CERTAIN MOTOR HOMES, WHEN THE COOKING RANGE AND FURNACE ARE OPERATING AT THE SAME TIME, THE FLAME ON THE COOKING RANGE COULD BE FORCED DOWNWARD OVER THE BURNER OR FLAME OUTAGE COULD OCCUR. THIS CONDITION IS DUE TO THE LOCATION OF THE FURNACE AND COOKING RANGE WHEREBY THE FURNACE MAY DRAW AIR IN FROM ABOVE THE RANGE BURNERS AND CAUSE A DOWNDRAFT.
Whether a recall was fixed on a particular car is known only to the manufacturer: check the VIN at nhtsa.gov/recalls.
NHTSA recalls · summaries in NHTSA's own words
Service bulletins
What Winnebago told its dealers about the 2004 Winnebago Sightseer: known faults, fixes and updates.
| Bulletin | Summary |
|---|---|
| 10252834 | Service Bulletin sent to dealers advising of the required legal verbiage each RO should document. |
| 10251128 | Service Bulletin sent to all Winnebago dealers. Bulletin outlines the characteristics of new roof sealant being used. |
| 10226724 | Service Bulletin sent to all Winnebago dealers. Bulletin advises of a manufacturing change to the shower surround sealant process for all units. |
| 10213593 | Service Bulletin sent to all dealers. This bulletin advises dealers they no longer need to email Winnebago the signed Vehicle Registration Form, but they should retain a copy for their records. |
| 10199382 | Service Bulletin to dealers reminding them to understand their state's Lemon Law and to comply with Winnebago Motorhome mandates outlined in the Policy & Procedure Manual. |
| 10199381 | Service Bulletin to dealers advising them of part sales training opportunities. |
| 10199380 | General Parts and Service Letter to dealers detailing the warranty part return procedure. |
NHTSA manufacturer communications (public domain)