Recalls in Canada
5 Transport Canada recalls for the 2023 Prevost H3-45 VIP.
| 2024151 6 Mar 2024 | Steering Issue: On a small number of vehicles, the steering column may not have been manufactured correctly. As a result, the steering shaft could separate from the un… |
| 2023378 12 Jul 2023 | Lights And Instruments Issue: On certain buses, the right-front turn signal lamp could fail when the turn signal or hazard warning lights are turned on. Safety Risk: A turn si… |
| 2023379 11 Jul 2023 | Lights And Instruments Issue: Certain buses were built with daytime running lamps (DRLs) that don't turn off when the fog lights are switched on. Canadian regulations require the DR… |
| 2023154 20 Mar 2023 | Lights And Instruments Issue: On a small number of vehicles, when the hazard lights are switched on with the ignition switch in the "OFF" position, the signal lamps may not flash at… |
| 2023097 24 Feb 2023 | Accessories Issue: On certain vehicles, the fire sensor located in the engine compartment could fail. If this happens, the automatic fire suppression system (AFSS) could a… |
Transport Canada Vehicle Recalls Database · Contains information licensed under the Open Government Licence – Canada
Recalls
Prevost Car (US) Inc. (Prevost) is recalling certain 2023 H3-45 and 2022-2023 H3-45 VIP vehicles. The steering column joints may fail, causing a loss of steering control.
Prevost Car (US) Inc. (Prevost) is recalling certain 2024 H3-45 and 2022-2024 H3-45 VIP motorcoaches equipped with Prevost Driver Assist. The radar sensor may be obstructed by an incorrect front bumper trim panel, causing the driver assist system to not function properly.
Prevost Car (US) Inc. (Prevost) is recalling certain 2024 H3-45, 2023-2024 H3-45 VIP, X3-45 VIP, X3-45 VIP Entertainer, and 2023 X3-45 motor coaches. The grid heater cables that connect to the relay may have a loose connection and cause the relay to overheat.
Prevost Car (US) Inc. (Prevost) is recalling certain 2023-2024 H3-45 and 2022-2024 H3-45 VIP vehicles. The right front turn signal light may fail when the turn signal or hazard warning lights are activated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Prevost Car (US) Inc. (Prevost Car) is recalling certain 2022-2023 H3-45 VIP and 2023 H3-45 vehicles. When activating the hazard warning lights, the turn signal lights may not flash simultaneously if the ignition is off. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
Prevost Car (US) Inc. (Prevost) is recalling certain 2018-2023 H3-45 motor coaches and H3-45 VIP motorhomes, and 2019 H3-41 motor coaches. The Automatic Fire Suppression System (AFSS) optical fire sensor positioned in the engine compartment's lower region may corrode and malfunction. In this event, the AFSS may give a false warning to the driver, command an unwarranted engine shutdown, and release a chemical fire extinguishing agent in the engine compartment.
Prevost Car (US) Inc. (Prevost) is recalling certain 2010-2023 H3-45, H3-45 VIP, X3-45, X3-45 Com, and X3-45 VIP vehicles. In the event of the alternator front bearing seizing, the alternator belt may continue to operate, causing the bearing to overheat.
Whether a recall was fixed on a particular car is known only to the manufacturer: check the VIN at nhtsa.gov/recalls.
NHTSA recalls · summaries in NHTSA's own words
Service bulletins
What Prevost told its dealers about the 2023 Prevost H3-45 VIP: known faults, fixes and updates.
| Bulletin | Summary |
|---|---|
| 11003159 | Sway bar collars improvement. Revision A : Add front sway bar support replacement and change bolts lenght. |
| 10252408 | On the vehicles affected by this bulletin, the electronic mirror lens air-cleaning system may not work. |
| 10252405 | On the vehicles affected by this bulletin, the DPF harness possibility needs to be replaced to avoid oxidation. |
| 10248284 | On the vehicles affected by this bulletin, the wiper motor harness needs a modification to avoid connector terminals corrosion. |
| 10248282 | On the vehicles affected by this bulletin, headlamps may have a premature deterioration of the aesthetics of the internal surface. This issue has no impact on the performance and quality of the headlamp. See procedures for replacement by improved headlamps. Revision A: Parts list change |
| 10248281 | On the vehicles affected by this bulletin, headlamps may have a premature deterioration of the aesthetics of the internal surface. This issue has no impact on the performance and quality of the headlamp. See procedures for replacement by improved headlamps. |
| 10248275 | SWAY BAR COLLARS IMPROVEMENT |
| 10240150 | On the vehicles affected by this bulletin it is possible that there is a lack of glue on the mirror support. If this is the case, you will need to add it to eliminate the risk of the front-end fiber cracking when tightening the mirror bolts. |
| 10238423 | Window Gaps Minimum Clearance on Converted Shells |
| 10233625 | On the vehicles affected by this bulletin, the Vehicle Emission Control Information label must be replaced. Revision: B - Causal part changed, was 010352, becomes 85152363. No impact on procedure or parts involved. |
| 10233622 | Prevost Driver Assist System Description. Revision A - EFFECTIVE ON H3-45 SERIES UP TO VEHICLE P-1452 |
| 10233619 | On the vehicles affected by this bulletin, follow the procedure to correctly connect the connector over the pump. Revision: A - Add information to Depressurized the cooling system |
| 10231093 | STEERING GATEWAY. Revision B - PIN 2 and 10 were inverted on connector A139 |
| 10228667 | Air Tanks Draining Sequence. Revision: B - General Update |
| 10226928 | Air Tanks Draining Sequence. Revision: A - Erroneous Secondary & Accessory tanks location. |
| 10226927 | Air Tanks Draining Sequence |
| 10222380 | TAG AXLE HUB FLANGE - ALTERNATE CAP SCREW |
| 10219023 | STEERING GATEWAY, revision A : Cancel watch dog removal from EFD part of the instruction |
NHTSA manufacturer communications (public domain)
NHTSA investigations
Alternator Front Bearing Failure
NHTSA Office of Defects Investigation