Recalls in Canada
2 Transport Canada recalls for the 2016 Volvo VNX.
| 2016077 18 Feb 2016 | Steering On certain vehicles manufactured with a 2-piece steering shaft, the lower or upper steering shaft may disconnect from the coupler. Separation would result in co… |
| 2015561 24 Nov 2015 | Steering On certain vehicles manufactured with a 2-piece steering shaft, the bolt torque on the joint that couples the upper and lower steering shaft could be lower than… |
Transport Canada Vehicle Recalls Database · Contains information licensed under the Open Government Licence – Canada
Recalls
Volvo Trucks North America (Volvo) is recalling certain model year 2016-2017 VNL, VNX, and VNM trucks manufactured from May 11, 2015, through April 18, 2016. The trucks may have been manufactured without a roll pin on the steering shafts. If the roll pin is missing, the lower steering shaft may disconnect from the junction block. Also, the bolt connecting the upper steering shaft to the lower steering shaft may not have been properly tightened. Either condition can lead to separation of the steering shaft.
Volvo Trucks North America (Volvo) is recalling certain model year 2015 and 2016 VNX and VNL trucks manufactured from May 20, 2014, through March 6, 2015, equipped with certain Haldex Life Seal Type 30/30 Long Stroke Air Brake Actuators manufactured January 9, 2014, to October 28, 2014. The affected actuators may have an incomplete attachment of the internal rubber diaphragm to the actuation mechanism of the parking brake section of the Life Seal actuator.
Whether a recall was fixed on a particular car is known only to the manufacturer: check the VIN at nhtsa.gov/recalls.
NHTSA recalls · summaries in NHTSA's own words
Service bulletins
What Volvo told its dealers about the 2016 Volvo VNX: known faults, fixes and updates.
| Bulletin | Summary |
|---|---|
| 10251325 | CBR - Telematics Gateway (TGW) Connect Ability Issues. |
| 10251323 | CBR - Active "Set Park Brake" Message On Drivers Information Display (DID) |
| 10251319 | CBR - Automated Manual Transmission ( AMT ) Flywheel Pilot Bearing Wear On Input Shaft. |
| 10251317 | CBR - Driveline Noise, Suspension Ride Height Too High, Suspension Will Not Exhaust - Chassis Built 2016w01 And Newer |
| 10249569 | CBR: TGW Will Not Connect After SIM Card Replacement |
| 10248086 | Emissions Campaign: Volvo has determined that certain 2014 -2018 model year VN, VHD, and VAH Vehicles require a replacement Diesel Particulate Filter (DPF) along with updated software. |
| 10244825 | CBR: Vehicle Speed Factor (K-Factor) Programming - Speed Factor Value Incorrect When Calculated In Premium Tech Tool (PTT); Speedometer Reading Incorrectly Following A Change To Vehicle Speed Factor - US17+OBD16 And Newer Emissions, Common Model Year 2018. |
| 10243461 | TSB: Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement |
| 10243460 | TSB: Aftertreatment Diesel Exhaust Fluid (DEF) Tank, Level Sensor, Replacement |
| 10241906 | TSB: Barksdale Leveling Valve, Leak Test |
| 10241904 | CBR: Volvo VHD & VN Models - Vehicle Wil Not Start, PTO Active Message Displayed In Cluster, PTO Light On When PTO Switch Is Turned Off |
| 10240252 | CBR: Volvo DEF Dosing Valve Diagnostic Trouble Codes (DTC) P202D00, P208E00, P103B00 - US10+OBD13 And Newer Emissions |
| 10240244 | CBR: Programming Failure - Chassis With Cummins Engine And An Allison Transmission |
| 10233504 | Volvo Chassis - Electronically Controlled Air Dryer System (ECADS) Building Too Much Air Pressure; Pressure Relief Valve Opening |
| 10227196 | Volvo Chassis - Model VNX - One piece Propeller Shaft ( Drive Shaft ) Contacts Cross Member |
| 10225706 | Volvo DEF Pump Troubleshooting Guide - US10+OBD13 And Newer Emissions |
| 10225704 | Volvo Chassis - ( AMT, I-Shift ) - Transmission Grinding When Downshifting ; Range Synchronizer (Synchro) Timing Procedure - US07 And Newer |
| 10225683 | Vehicle Overspeed Warning Comes Active At A Lower Speed Than Expected; Vehicle Overspeed Warning In Driver Information Display (DID) - Model Year 2018 And Newer With New Style Instrument Cluster |
| 10225675 | Diagnostic Trouble Codes (DTC) P24F600 Or P24F700 - US14+OBD15 Emissions And Newer, Model Year 2016 And Newer |
| 10224584 | Expendable Items Parts List. |
| 10222288 | Diagnostic Trouble Code P200200 - Diagnostic Information; US14+OBD16 And Newer Emissions |
| 10222270 | TSB-Charge Air Cooler t-clamp install. |
| 10219421 | Engine Control Module (EMS) Software (MSW) Information August 2022; Improvement List (Change Log) - US21+OBD22 (13L VGT, TC) And US17+OBD22 (11L) Emissions |
| 10219302 | Part information for AMT input shaft repair kits and the shim kit that is required for repair. |
| 10215308 | Volvo Chassis - Equipped with An Automated Manual Transmission (AMT, iShift) - SNV 19-002 - AMT Oil Filter Housing Corrosion |
NHTSA manufacturer communications (public domain)
NHTSA investigations
Discrepancies in Required CFR Reporting
NHTSA Office of Defects Investigation