Compared with other years
NHTSA ODI complaints by model year
Recalls in Canada
6 Transport Canada recalls for the 2011 Pierce Arrow XT.
| 2015005 8 Jan 2015 | Suspension On certain vehicles, the lower control arms may have developed cracks at time of manufacture and may fail. This could cause partial suspension failure and could… |
| 2013386 4 Nov 2013 | Electrical On certain trucks, the trailer wiring connector may have been incorrectly wired so that a stop signal overrides the turn signal. As a result, trailer lights wou… |
| 2012212 13 Jul 2012 | Fuel System On certain fire trucks equipped with a Detroit Diesel DD13 engine, the support system for the high pressure fuel line (between the fuel pump and the fuel delive… |
| 2012077 27 Feb 2012 | Engine On certain emergency vehicles, the engine shutdown system (normally provided to protect the engine in case of malfunction) may not have been disabled during veh… |
| 2011402 14 Nov 2011 | Other On certain fire trucks, specific operating conditions (such as tight, successive, highly banked curves in opposite directions), could trigger unintended Electro… |
| 2011158 18 Apr 2011 | Engine On certain fire trucks, the air cleaner support bracket fasteners may loosen and fall out. This could allow the air cleaner and bracket to fall onto the engine… |
Transport Canada Vehicle Recalls Database · Contains information licensed under the Open Government Licence – Canada
Recalls
Pierce Manufacturing (Pierce) is recalling certain 2010-2022 Pierce Velocity, Enforcer, Arrow XT, Quantum, and Dash CF fire trucks. Stokes basket mounting brackets may be insufficiently welded.
Pierce Manufacturing (Pierce) is recalling certain 2004-2018 Arrow XT, Dash, Enforcer, Impel, Quantum and Velocity aerial vehicles. The aerial device may unexpectedly rotate to the right when the ladder is being extended.
Pierce Manufacturing (Pierce) is recalling certain 2007-2017 Pierce Velocity, Impel, Arrow-XT, Quantum, and Enforcer emergency response vehicles equipped with 75ft aerial devices with a 21 inch or 28 inch limited retraction bracket. The bracket on the aerial device may detach from the aerial and fall to the ground.
Pierce Manufacturing (Pierce) is recalling certain 1999-2013 Arrow XT, Dash, Enforcer, Quantum and Velocity fire trucks equipped with the electric All-steer rear steering option. The affected vehicles have rear steer axle shafts that were not properly heat treated.
Pierce Manufacturing (Pierce) is recalling certain model year 2010-2016 Arrow-XT, Quantum, and Velocity vehicles manufactured from October 30, 2010, through January 24, 2016. The affected vehicles are equipped with Pelican 9410L flashlights, part number 9410-021-245 or 9410-021-110, with lithium ion battery packs which may overheat.
Pierce Manufacturing (Pierce) is recalling certain model year 2009-2013 Pierce Enforcer, Impel, Quantum, Velocity, and Arrow XT emergency vehicles manufactured November 11, 2009, to April 23, 2013, and equipped with TAK-4 front independent suspensions. The affected vehicles have front lower control arms that may crack and fracture.
Pierce Manufacturing Inc. (Pierce) is recalling one model year 2009 Enforcer emergency vehicle and certain model year 2009-2013 Arrow XT, Saber, Velocity, Impel, Quantum, and Commercial vehicles. The trailer connector circuit was wired such that the stop signal overrides the turn signal and the trailer lights do not indicate a turn when brakes are applied.
PIERCE IS RECALLING CERTAIN MODEL YEAR 2010-2012 VEHICLES MANUFACTURED FROM AUGUST 28, 2010, THROUGH MARCH 27, 2012, EQUIPPED WITH DETROIT DIESEL DD13 EPA 2007 AND EPA 2010 DIESEL ENGINES. THE PUMP TO RAIL HIGH PRESSURE FUEL LINE SUPPORT SYSTEM USED ON THESE ENGINES IS SENSITIVE TO ASSEMBLY TORQUE AND MAY BE DAMAGED DURING SERVICE WORK. AS A RESULT OF OTHER REPAIRS, THE LINE SUPPORTS MAY LOOSEN, POTENTIALLY LEADING TO FUEL LINE CRACKING AND A FUEL LEAK.
PIERCE IS RECALLING CERTAIN MODEL YEAR 2010-2012 ARROW XT, DASH CF, QUANTUM AND VELOCITY EMERCENCY VEHICLES MANUFACTURED FROM OCTOBER 13, 2010, THROUGH FEBRUARY 8, 2012, AND EQUIPPED WITH DETROIT DIESEL DD13 EPA 2010 ENGINES. THE ENGINE SHUTDOWN SOFTWARE NORMALLY PROVIDED TO PROTECT THE ENGINE AND VEHICLE MAY NOT HAVE BEEN DISABLED ON ENGINES INTENDED FOR EMERGENCY VEHICLE APPLICATIONS.
PIERCE MANUFACTURING (PIERCE) IS RECALLING CERTAIN MODEL YEAR 2007-2011 ARROW XTAND VELOCITY, MODEL YEAR 2008-2011 CUSTOM CONTENDER, IMPEL, QUANTUM AND MODEL YEAR 2009-2011 SABER EMERGENCY TRUCKS, EQUIPPED WITH MERITOR WABCO ELECTRONIC STABILITY CONTROL (ESC) MODULES, MANUFACTURED FROM DECEMBER 19, 2007, THROUGH OCTOBER 7, 2011. UNDER CERTAIN ROAD AND DRIVING CONDITIONS, VEHICLE BODY ROLL AND ROAD INCLINATION CHARACTERISTICS MAY ADVERSELY AFFECT THE SLIP ANGLE CALCULATION OF THE ELECTRONIC STABILITY CONTROL (ESC) SYSTEM. THIS MIGHT CAUSE THE ESC TO PERCEIVE AN OVER STEERING SITUATION AND THEREFORE APPLY THE OUTER WHEEL BRAKE ON THE FRONT AXLE UNTIL THE VEHICLE IS PERCEIVED TO BE STABLE.
PIERCE IS RECALLING CERTAIN MODEL YEAR 2011 ARROW XT, CUSTOM CONTENDER, DASH CF, IMPEL, SABER, AND VELOCITY EMERGENCY VEHICLES MANUFACTURED FROM JANUARY 24, 2011, THROUGH APRIL 19, 2011, EQUIPPED WITH A CUMMINS ISB, ISX, ISC, OR ISL DIESEL ENGINE. THE V-BAND CLAMP ASSEMBLY, PART NUMBERS Q187684, Q187685, AND Q187686, USED TO CONNECT THE INLET AND OUTLET CONE SECTIONS TO THE DIESEL OXIDATION CATALYST (DOC)/DIESEL PARTICULATE FILTER (DPF) INCLUDE A T-BOLT WHICH CAN FRACTURE AND FAIL WHEN SUBJECTED TO STRESS OR LOAD. A FRACTURE OR FAILURE OF THE T-BOLT MAY CAUSE THE CLAMP TO LOOSEN AND THE INLET OR OUTLET SECTIONS ATTACHED TO THE DOC/DPF HOUSING TO DISCONNECT.
PIERCE IS RECALLING CERTAIN MODEL YEAR 2009-2011 ARROW XT AND VELOCITY FIRE APPARATUS MANUFACTURED FROM JUNE 30, 2009, THROUGH MARCH 15, 2011. THE FRONT AXLE OF THESE VEHICLES WERE BUILT WITH MICHELIN 365/70R22.5 XZA TIRES INSTALLED ON 12.25 INCH WIDE WHEELS. THESE TIRES REQUIRE 10.5 INCH WIDE WHEELS. THEREFORE, THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Whether a recall was fixed on a particular car is known only to the manufacturer: check the VIN at nhtsa.gov/recalls.
NHTSA recalls · summaries in NHTSA's own words
Service bulletins
What Pierce told its dealers about the 2011 Pierce Arrow XT: known faults, fixes and updates.
| Bulletin | Summary |
|---|---|
| 11011818 | This bulletin is to support the dealer network when replacing a ASL 360 ECU that requires programming on the truck. |
| 11011817 | Software update for fault codes on Command Zone display: This software update may help remove ambiguity between active and inactive engine error codes shown on the Command Zone display. |
| 11008386 | All Roto Rays are warranted to the purchaser for twenty-four months from the date of service against defects in material or workmanship. During the warranty period products found to be defective will be repaired or replaced (at Roto Rays option) without charge. The defective light must be returned to Roto Rays, INC., 722 Park Ave., Herndon, VA 20170. The light will be returned to the purchaser prepaid. |
| 10238853 | In Arrow XT custom chassis, the A/C condensation pan may overflow and drip on driver and occupants. Previously, an engineering review was required before modifying the cabin. This bulletin streamlines the process and an engineering review is no longer required. |
| 10210778 | The GEN 1 Husky 3 foam pump from FSC is being discontinued. To keep supporting our customers, a conversion kit is available to install the GEN 2 Husky 3 foam pump in place of the GEN 1. |
| 10197419 | Recall - Notice: 14V-660-Tak-4 Lower Control Arm Vehicle Safety Recall dealer nofication-Important. Pierce Manugacturing has determined that a defect which relates to motor vehicle safety exists in certain Impel, Quantum, Velocity, and Arrow XT custom fire apparatus models manufactured between 2009 and 2013 equipped with TAK-4 indekpendent susfpensions. |
| 10052300 | PIERCE: THE FEMALE BUCKLE AND BELT TONGUE HAS BEEN UPGRADED TO A NEW COMBINATION L9, THAT PROVIDES MORE STRAIN RELIEF FOR WIRING IN STALK, AND SHOULDER BELT SYSTEM HAS A NEW READY REACH D-LOOP ASSEMBLY ON CERTAIN MODELS. MODELS VELOCITY, IMPEL, ARROW XT, QUANTUM, DASH CF. MODEL YEARS NOT LISTED. *PE |
NHTSA manufacturer communications (public domain)
NHTSA investigations
Unintended aerial platform movement
Front suspension ball joint failure
Front Lower Control Arm Failing
NHTSA Office of Defects Investigation