Problems owners report
Complaints filed with NHTSA about the 2007 Freightliner Cascadia, by the system named in each complaint. One complaint can name several.
- Steering1
NHTSA ODI complaints (public domain) · updated 23 Oct 2026 · 0 injuries and 0 deaths reported
Compared with other years
NHTSA ODI complaints by model year
Recalls in Canada
11 Transport Canada recalls for the 2007 Freightliner Cascadia.
| 2020158 14 Apr 2020 | Lights And Instruments Issue: On certain trucks equipped with "Fleet Engineer" mud flaps, the bracket for the mud flaps may partially cover the rear reflective tape. Canadian regula… |
| 2015113 16 Mar 2015 | Lights And Instruments On certain vehicles water intrusion could occur, and corrode and damage inside of the Signal-detect and Activation Module (SAM) Chassis. This corrosion could c… |
| 2012080 27 Feb 2012 | Fuel System On certain trucks equipped with a Detroit Diesel DD13, DD15 or DD16 engine, the support system for the high pressure fuel line (between the fuel pump and the fu… |
| 2011411 21 Nov 2011 | Other On certain vehicles equipped with an MBE4000 (EPA07) engine, the intake air grid heater may short circuit and fail. This could result in a vehicle fire causing… |
| 2011367 14 Oct 2011 | Steering On certain trucks equipped with a rack & pinion steering system, the lower pinion bearing may corrode and fail. As a result, the vehicle may require additional… |
| 2011345 19 Sept 2011 | Fuel System On certain trucks, the plastic low-pressure fuel line between the engine-mounted fuel filter and the engine block may develop a diesel fuel leak. The location … |
| 2011346 19 Sept 2011 | Other On certain vehicles, specific operating conditions (such as tight, successive, highly banked curves in opposite directions), could trigger unintended Electronic… |
| 2009287 5 Oct 2009 | Fuel System On certain trucks, the plastic low-pressure fuel line may fatigue crack and leak. Diesel fuel leakage may ignite on a hot engine surface and cause a fire, whic… |
| 2009259 9 Sept 2009 | Steering On certain trucks, the left inner tie rod end may loosen and eventually separate from the steering rack. Tie rod failure could result in a loss of steering con… |
| 2009009 12 Jan 2009 | Electrical On certain trucks, the Chassis and Cab Signal-detect and Activation Modules (SAMs) may suffer water intrusion, which could cause an electrical short or intermit… |
| 2007359 7 Nov 2007 | Other On certain trucks, the fifth wheel hitch assembly's lever arm may have been incorrectly installed during the manufacturing process. The lever arm pivot bolt ma… |
Transport Canada Vehicle Recalls Database · Contains information licensed under the Open Government Licence – Canada
Recalls
Daimler Trucks North America LLC (DTNA) is recalling certain 2002-2017 Freightliner Cascadia, Century Class, Columbia and Coronado trucks and Western Star 4700, 4900, 5700, 5900 and 6900 trucks. These vehicles are equipped with Kidde Plastic-Handle or Push Button 'Pindicator' Fire Extinguishers that may become clogged, preventing the extinguisher from discharging as expected or excessive force may be needed to activate the extinguisher. Additionally, in certain models, the nozzle may detach from the valve assembly with enough force that it could cause injury and also render the product inoperable. For a full list of the affected fire extinguisher models visit: https://static.nhtsa.gov/odi/rcl/2017/RMISC-17E062-5427.pdf
Daimler Trucks North America LLC (DTNA) is recalling certain model year 2007-2011 Freightliner Cascadia trucks manufactured March 26, 2007, to August 31, 2010. Water may leak into the Signal-detection and Activation Module (SAM) Chassis causing corrosion which may result in electrical shorts or possible intermittent operation of trailer lights.
DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2006-2013 FREIGHTLINER, STERLING, AND WESTERN STAR VEHICLES, EQUIPPED WITH DETROIT DIESEL EPA07 AND EPA10, DD13 AND DD15/16 ENGINES, MANUFACTURED FROM JANUARY 20, 2006, THROUGH FEBRUARY 20, 2012. THE PUMP TO RAIL HIGH PRESSURE FUEL LINE SUPPORT SYSTEM USED ON THESE ENGINES IS SENSITIVE TO ASSEMBLY TORQUE AND MAY BE DAMAGED DURING SERVICE WORK. AS A RESULT OF OTHER REPAIRS, THE LINE SUPPORTS MAY LOOSEN, POTENTIALLY LEADING TO FUEL LINE CRACKING AND A FUEL LEAK.
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2005-2011 FREIGHTLINER CASCADIA, COLUMBIA, CENTURY, CORONADO, AND CLASSIC XL TRUCKS MANUFACTURED FROM NOVEMBER 1, 2004, THROUGH JUNE 15, 2010 FOR THE RACK AND PINION STEERING SYSTEM. THE LOWER PINION BEARING MAY CORRODE AND FAIL. A FAILED BEARING MAY LEAD TO DAMAGE OF THE SPOOL VALVE SEALS. A DAMAGE SPOOL VALVE SEAL MAY ALLOW HYDRAULIC FLUID TO FLOW TO THE RIGHT OR LEFT TURN PORT INSTEAD OF FLOWING TO THE RETURN PORT.
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2004 THROUGH 2008 HEAVY TRUCKS MANUFACTURED FROM JULY 11, 2003, THROUGH SEPTEMBER 28, 2007, EQUIPPED WITH EPA04 MODEL MBE4000 ENGINES BUILT WITH PLASTIC LOW PRESSURE FUEL LINES AND FUEL FILTERS MOUNTED NEAR THE CENTER OF THE ENGINE ON THE LEFT-HAND SIDE. THE PLASTIC LOW PRESSURE FUEL LINE BETWEEN ENGINE MOUNTED FUEL FILTER AND ENGINE BLOCK MAY DEVELOP A SUBSTANTIAL DIESEL FUEL LEAK.
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2006-2012 FREIGHTLINER BUSINESS CLASS M2, CASCADIA, CENTURY, COLUMBIA, CORONADO AND STERLING A-LINE VEHICLES BUILT WITH MERITOR WABCO ELECTRONIC STABILITY CONTROL (ESC) SYSTEM MANUFACTURED FROM SEPTEMBER 15, 2005 THROUGH SEPTEMBER 1, 2011. UNDER CERTAIN ROAD AND DRIVING CONDITIONS, VEHICLE BODY ROLL AND ROAD INCLINATION CHARACTERISTICS MAY ADVERSELY AFFECT THE SLIP ANGLE CALCULATION OF THE ELECTRONIC STABILITY CONTROL (ESC) SYSTEM. THIS MIGHT CAUSE THE ESC TO PERCEIVE AN OVER STEERING SITUATION AND THEREFORE APPLY THE OUTER WHEEL BRAKE ON THE FRONT AXLE UNTIL THE VEHICLE IS PERCEIVED TO BE STABLE.
DAIMLER TRUCKS (DTNA) IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2011 FREIGHTLINER, CASCADIA, CENTURY, COLUMBIA FLD, AND M2, STERLING 9500, AND WESTERN STAR 4900 HEAVY TRUCKS MANUFACTURED FROM MARCH 20, 2006, THROUGH JUNE 30, 2010, EQUIPPED WITH SPECIFIC MBE4000 EPA07 MODEL ENGINES. THE INTAKE AIR GRID HEATER MAY SHORT CIRCUIT AND FAIL DUE TO EXCESSIVE INTERNAL TEMPERATURES.
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2011 FREIGHTLINER, FCCC, STERLING, AND WESTERN STAR HEAVY TRUCKS MANUFACTURED FROM SEPTEMBER 5, 2006, THROUGH JUNE 30, 2010, EQUIPPED WITH SPECIFIC MBE900 EPA04 AND EPA07 MODEL ENGINES. THE INTAKE AIR GRID HEATER MAY SHORT CIRCUIT AND FAIL DUE TO EXCESSIVE INTERNAL TEMPERATURES.
DAIMLER TRUCKS IS RECALLING MODEL YEAR 2007-2010 FREIGHTLINER, STERLING AND WESTERN STAR VEHICLES EQUIPPED WITH DETROIT DIESEL DD15 EPA07 ENGINES WHICH WERE MANUFACTURED WITH GRID HEATERS. INCREASED INTERNAL GRID HEATER RESISTANCE CAUSED BY IMPROPERLY TIGHTENED SCREWS MAY MELT THE SOLDER ON THE GRID HEATER CIRCUIT BOARD LEADING TO A SHORT CIRCUIT.
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2010 HEAVY TRUCKS MANUFACTURED BETWEEN JANUARY 17, 2006 AND MARCH 31, 2009, EQUIPPED WITH EPA07 MODEL MBE4000 ENGINES BUILT WITH PLASTIC LOW PRESSURE FUEL LINES. THE PLASTIC LINES MAY EXPERIENCE LEAKS DUE TO FATIGUE CRACKS CAUSED BY STRESS AND VIBRATION COMBINED WITH HIGH INTERNAL PRESSURE.
DAIMLER TRUCKS IS RECALLING CERTAIN MODEL YEAR 2005 THROUGH 2010 HEAVY DUTY TRUCKS MANUFACTURED FROM OCTOBER 29, 2005 THROUGH JULY 3, 2009. UNDER CERTAIN CONDITION, THE LEFT HAND INNER TIE ROD END MAY LOOSEN OVER TIME AND IF NOT CORRECTED, POTENTIALLY SEPARATE FROM THE STEERING RACK.
DAIMLER TRUCKS IS RECALLING 14181 MY 2007-2009 FREIGHTLINER CASCADIA TRUCKS EQUIPPED WITH CAB SIGNAL-DETECT AND ACTIVATION MODULES (SAMS). POTENTIAL CORROSION DAMAGE DUE TO WATER INTRUSION INTO THE SAMS MAY CAUSE ELECTRICAL SHORTS OR INTERMITTENT OPERATION OF TAIL LAMPS, STOP LAMPS, SIDE MARKER LAMPS AND TRAILER LIGHTING. IN SOME CASES STARTER MOTORS HAVE ACTIVATED WITHOUT A KEY ON.
Whether a recall was fixed on a particular car is known only to the manufacturer: check the VIN at nhtsa.gov/recalls.
NHTSA recalls · summaries in NHTSA's own words
Service bulletins
What Freightliner told its dealers about the 2007 Freightliner Cascadia: known faults, fixes and updates.
| Bulletin | Summary |
|---|---|
| 10236419 | ABS Light illuminating in the ICU. |
| 10236418 | ICUC Bulb check function. |
| 10209296 | Revised Freightliner Service Bulletin for ParkSmart Eberspaecher Auxiliary Heater Service. This bulletin replaces the version dated May 2015. The note in General Information has been revised to include New Cascadia. Espar information has been changed to reflect a company name change to Eberspaecher. |
| 10199899 | End of Production for the Freightliner P3 Cascadia Sales Cabs. Due to low production volumes, DTNA will be discontinuing the production of the Freightliner Cascadia P3 Sales Cabs. |
| 10195924 | SAM Cab & SAM Chassis Wall Charts |
| 10195913 | Cascadia Fault codes 6.0 |
| 10195716 | Odometer racks up mileage when the vehicle is stationary - Cascadia |
| 10195701 | Cascadia - Engine Will Not Crank (No Starter Output from SAM Cab) |
| 10195659 | SS 1032974 High Oil Pressure on 2017 DTNA Vehicles Instrument Cluster Display |
| 10195626 | SS 469068 Cascadia SAM Cab, SAM Chassis, MSF and CGW Hardware Compatibility |
| 10195593 | Service Solution SS 1033047 M2 Battery Drain Problem Mismatched I... |
| 10195576 | SS 1033121 Adding a Fan Override Switch (Legacy Cascadia) |
| 10195575 | Service Solution SS 1033094 KUS Float Tube Fuel Level Sensor Inform... |
| 10195478 | SS 1033638 - Power Window Express Down Module Discontinued |
| 10193732 | Freightliner Action Bulletin FAB158 Cummins Eaton SmartAdvantage |
| 10193710 | Freightliner Action Bulletin FAB154 New options for Cascadia |
| 10193705 | Freightliner Action Bulletin FAB153 New Harness Highway for Cascadia |
| 10193690 | Freightliner Action Bulletin FAB146 Cascadia LED headlights |
| 10193686 | Freightliner Action Bulletin FAB145 New Cascadia Roof Fairing |
| 10193645 | Freightliner Action Bulletin FAB144 Smartway Certification |
| 10190551 | Warranty Information letter announcing that DTNA is increasing the Standard Diagnostic Times (SDTs) shown. The updated after treatment system (ATS) diesel exhaust fluid (DEF) pump times will be applied to repair orders opened on or after April 12, 2021. |
| 10190549 | Warranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown. The updated times will be applied to repair orders opened on or after April 5, 2021. |
| 10185896 | Warranty Information Letter for Detroit New Service Replacement Engine SRT Update. While validating Standard Repair Times (SRTs) for Detroit's new Gen 5 engine series, DTNA discovered an error in a pre-Gen 5 SRT for the New Service Replacement Engine Program. As a result, DTNA re-studied the SRT and concluded that time for removing/re-installing multiple components (e.g., exhaust manifold/turbo, engine sensor harness, rocker arm assemblies, etc.) should not be included. |
| 10184785 | Revised Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring. Revision removed steps instructing removal and installation of wheels. Daimler Trucks North America has released a new axle shaft to hub rubber O-ring (part number 11-30728-000) as a replacement for the paper gasket (part number 11-14418-000). The new O-ring will provide better sealing and is reusable. It is quicker and easier to use compared to the paper gasket, because using a paper gasket requires cleaning the hub when the axle shaft is removed. |
| 10181759 | Updated Freightliner Service Bulletin for Powernet Troubleshooting Guide - Batteries, Path, Alternator, and Starter. This bulletin replaces the version dated 5/31/2017. Information is added about the BCT-460DTNA PowerNet Assessment Tool. When troubleshooting Powernet issues, use the BCT-460DTNA PowerNet Assessment Tool. As of May 29, 2018, the AutoMeter is the only Daimler-approved tool for troubleshooting vehicle Powernet issues. |
NHTSA manufacturer communications (public domain)
NHTSA investigations
SAM Cab Water Intrusion
Daimler Trucks North America Recalls
RACK AND PINION FAILURE
NHTSA Office of Defects Investigation