Compared with other years
NHTSA ODI complaints by model year
Recalls in Canada
8 Transport Canada recalls for the 2008 Mack CXU.
| 2014527 20 Nov 2014 | Electrical On certain model vehicles, water around the windshield can migrate into the Electronic Power Distribution Module and contaminate it. As a result, circuits may … |
| 2012300 5 Sept 2012 | Lights And Instruments On certain trucks, an electrical short circuit in the fog light circuitry could result in a loss of low beam headlamp function. Loss of headlamp illumination, … |
| 2007368 14 Nov 2007 | Steering On certain trucks, the bolts that attach the steering gear to the frame may not have been tightened to the specified torque. This could allow the bolts to loos… |
| 2007339 19 Oct 2007 | Other On certain trucks, the fifth wheel hitch assembly's lever arm may have been incorrectly installed during the manufacturing process. The lever arm pivot bolt ma… |
| 2007325 10 Oct 2007 | Lights And Instruments On certain trucks, the Daytime Running Light (DRL) module may overheat and cause a vehicle fire. Correction: Dealers will replace the DRL module. |
| 2007264 14 Aug 2007 | Brakes On certain vehicles, the internal rubber check valve inside the Bendix SR-7 spring brake modulating valve can become deformed over time. The effect of this def… |
| 2007265 14 Aug 2007 | Brakes On certain school and transit buses, the Parker single check valve (SCV) that connects with the supply port of the Bendix SR-7 spring brake modulating valve may… |
| 2007256 7 Aug 2007 | Fuel System On certain trucks, when the ignition key is in the 'ON' position, the pre-heater, located in the fuel filter base, is energized. If this pre-heater is energize… |
Transport Canada Vehicle Recalls Database · Contains information licensed under the Open Government Licence – Canada
Recalls
Mack Trucks, Inc. (Mack) notified the agency on February 20, 2014, that they are recalling certain model year 2010-2012 CHU, CXU, GU and TD vehicles manufactured from June 16, 2009, through July 8, 2011. While continuing to research the scope of the issue, Mack expanded the recall on November 18, 2014 to include certain model year 2008-2009 and 2013-2014 CHU, CXU, GU and TD vehicles manufactured from June 16, 2009, through July 8, 2011. Having completed its investigation, Mack once again expanded the recall during February 2015 to include an additional 53,780 vehicles from model years 2007 and 2015. The recall now covers model year 2007-2015 includes CHU, CXU, GU and TD vehicles produced October 13, 2006, through October 3, 2014. In the affected vehicles, the Electronic Power Distribution Module (EPDM) may be contaminated from water leaks in, and around, the windshield. If exposed to water leaks, contaminants such as road salts may deposit on the EPDM.
Mack is recalling certain model year 2007-2010 CHU and CXU vehicles, manufactured from October 13, 2006, through December 23, 2009 and equipped with daytime running lights and fog lights. A short in the fog light circuit may cause the low beam headlight circuit to cut out.
ON CERTAIN TRUCKS, THE BOLTS THAT ATTACH THE STEERING GEAR TO THE FRAME MAY NOT HAVE BEEN TIGHTENED TO THE SPECIFIED TORQUE.
ON CERTAIN TRUCKS EQUIPPED WITH A SAF HOLLAND SIMPLEX FIFTH WHEEL, THE LEVER ARM PIVOT BOLT MAY HAVE BEEN OVER TIGHTENED. AN OVER TIGHTENED PIVOT BOLT CAN DISTORT THE PIVOT BOLT SPACER SLEEVE, WHICH MAY PREVENT THE FIFTH WHEEL LATCH JAW FROM CLOSING AND LATCHING SECURELY AROUND THE TRAILER KING PIN.
ON CERTAIN TRUCKS, THE DAYTIME RUNNING LIGHTS (DRL) MODULE MAY CONTAIN A SUSPECT METAL-OXIDE-SEMICONDUCTOR FIELD EFFECT TRANSISTOR (MOSFET) THAT COULD OVERHEAT.
ON CERTAIN TRUCKS EQUIPPED WITH PARKER SINGLE CHECK VALVES (SCV) PROVIDED BY BENDIX. THE DEFECT EXISTS IN THE PARKER SCV THAT CONNECTS WITH THE SUPPLY PORT OF THE SR-7 SPRING BRAKE MODULATING VALVE. AFTER PROLONGED USE OF THE PARKER SCV, THE VALVE BODY RETAINER MAY BECOME EXCESSIVELY WORN AND EVENTUALLY BREAK APART. PIECES OF THE PARKER SCV CAN BECOME LODGED INSIDE THE SR-7 SPRING BRAKE MODULATING VALVE, POTENTIALLY CAUSING EITHER LEAKAGE OUT OF THE SR-7 VALVE OR PREVENTING AIR FROM PROPERLY EXHAUSTING FROM THE SR-7 VALVE.
ON CERTAIN TRUCKS EQUIPPED WITH BENDIX SR-7 SPRING BRAKE MODULATING VALVES, THE INTERNAL RUBBER CHECK VALVE MAY LEAK CAUSING A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AFTER THE OPERATOR PULLS THE DASH VALVE BUTTON.
Whether a recall was fixed on a particular car is known only to the manufacturer: check the VIN at nhtsa.gov/recalls.
NHTSA recalls · summaries in NHTSA's own words
Service bulletins
What Mack told its dealers about the 2008 Mack CXU: known faults, fixes and updates.
| Bulletin | Summary |
|---|---|
| 11008366 | CBR: To correct the MID136 SID 66 FMI 7 fault code the latest Bendix VCP fi le will need to be downloaded. |
| 11003042 | CBR - Accelerator Pedal: Inspection Instructions |
| 11000831 | CBR: Vehicles built with an 11 liter engine may experience a complaint of excessive fuel in the oil. It is possible that the source of the fuel is the rear fuel galley plug in the cylinder head. A new and improved fuel galley plug has been developed to resolve this issue. |
| 10251331 | CBR - Active "Set Park Brake" Message On Drivers Information Display (DID). |
| 10251329 | CBR - Automated Manual Transmission ( AMT ) Flywheel Pilot Bearing Wear On Input Shaft. |
| 10246086 | TSB: Mack Trucks now offer an improved HD Inter-Axle Through Shaft for the CRD 125, 150, 180, and 200 family carriers. The new HD shaft went into production on January 23rd, 2023 for 2.54 - 3.50 axle ratios and April 1st, 2023 for 3.56 - 3.98 ratios. The new HD through shaft is an upgrade over the current standard shaft and can now be used as a replacement part instead of the standard shaft. The new HD shaft has a new design to increase strength, longevity and life over the standard shaft. |
| 10241946 | TSB: Barksdale Leveling Valve, Leak Test |
| 10241945 | TSB: Air Restriction Indicator |
| 10237342 | CBR: Diagnostic Trouble Code (DTC) P215A-64, Fault Code SPN 84 FMI 19 |
| 10237339 | CBR: eWarranty To UCHP Labor Code ( SCC Code ) Crossover, Conversion Information For Use With Campaigns ( FI, PI ) And Recalls ( EC, SC ), Location On Trucks Dealer Portal ( TDP ) |
| 10235490 | TSB: Vibration Diagnostics |
| 10235489 | TSB: Stock Vehicle Storage and Maintenance |
| 10235486 | TSB: New Vehicle Safety Certification Requirements for Vehicles, U.S. and Canada |
| 10232613 | Mack MMD Alternator Pulley |
| 10232599 | Flywheel Housing Thread Repair |
| 10232598 | Instrument Cluster Programming - Programming Fails Or Errors Display When Replacing An Instrument Cluster With A Newer Part Number (Conversion Kit) - US04 To US10 Chassis (9-Pin Diagnostic Connector) |
| 10225660 | 2007 document reformatted to be published as a TSB in Impact.Coolant level sensor. |
| 10225657 | 2007 document reformatted to be published as a TSB in Impact.Clutch air assist cylinder vent. |
| 10225656 | 2007 document reformatted to be published as a TSB in Impact. Cab height adjustment. |
| 10225654 | 2008 document reformatted to be published as a TSB in Impact. ABS sensor mounting bracket. |
| 10225653 | 2008 document reformatted to be published as a TSB in Impact. Revised upper coolant hose. |
| 10225651 | 2008 document reformatted to be published as a TSB in Impact. Air conditioner evaporator freeze up fault. |
| 10225650 | 2008 document reformated to be published as a TSB in Impact. Windshield wiper arm nozzle. |
| 10225649 | 2008 document reformatted to be published as a TSB in Impact. T300 transmission synchronizers repair. |
| 10225646 | 2008 document reformated to be published as a TSB in Impact. Injector rocker arm service. |
NHTSA manufacturer communications (public domain)
NHTSA investigations
AIR BRAKE SYSTEM CONTROL VALVES
AIR BRAKE CONTROL VALVE
AIR COMPRESSOR DISCHARGE LINE
NHTSA Office of Defects Investigation