MCI E4500

Motor Coach Industries (MCI) is recalling certain 102DL3, 102D3, MC12PTV, E4500, D4000, 102D3ISTV, D4500, J4500, D4000ISTV, D4005, D4505, and J3500 transit buses. Please refer to MCI's recall report for specific model year information. The front door lower curb view glazing material is incorrect. As such, these vehicles fail to conform to Federal Motor Vehicle Safety Standard (FMVSS) number 205, "Glazing Materials."

Motor Coach Industries (MCI) is recalling certain 2005-2009 E4500 and 2005-2012 J4500 motorcoaches equipped with Ricon Baylift Wheelchair Lifts. When the lift's outer barrier is fully deployed, it may not withstand a sufficient amount of force, which could cause it to fail. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 403, "Platform Lift Systems," and number 404, "Platform lift installations."

Motor Coach Industries (MCI) is recalling certain 2001-2015 J4500 and 1997-2013 102EL3/E4500 coaches equipped with a hydraulic rear axle (tag axle) steering system. The axle's alignment and low hydraulic pressure in the steering system may cause the steering system to lock, causing a loss of steering control at highway speeds.

Motor Coach Industries (MCI) is recalling certain model year 2007-2010 MCI E4500 and J4500 motor coaches manufactured November 21, 2006, to August 27, 2009, and equipped with certain Recaro Automotive Seating Ergo M bus driver seats. The affected seats were manufactured in a way that the tether bar may push into the retractor panel door and potentially interfere with the seat belt locking mechanism.

Motor Coach Industries (MCI) is recalling certain model year 2009-2014 E4500 and J4500 motorcoaches manufactured October 2008 through October 2013, and equipped with passenger seats with 3-point seat belts. The seat track for the second row passenger seats may be missing a weld at the end of the seat track where it enters the frame structure.

Motor Coach Industries (MCI) is recalling certain model year 2000-2012 D, E, G and J series coaches manufactured January 2000 through June 2011 and equipped with Sure Power battery equalizers containing a particular epoxy sealing, aka 'potting', compound. The specific potting compound used in the subject products for insulation was found to be capable of conducting electricity after being exposed to heat.

MOTOR COACH INDUSTRIES (MCI) IS RECALLING CERTAIN MODEL YEAR 2003, AND 2007-2012 E AND J MODELS ALONG WITH MODEL YEAR 2007-2012 D4000, D4005, D4500, D4505, D4000ISTV MOTOR COACHES EQUIPPED WITH MERITOR WABCO ELECTRONIC STABILITY CONTROL (ESC) MODULES, MANUFACTURED FROM OCTOBER 2002, THROUGH OCTOBER 2011. UNDER CERTAIN ROAD AND DRIVING CONDITIONS, VEHICLE BODY ROLL AND ROAD INCLINATION CHARACTERISTICS MAY ADVERSELY AFFECT THE SLIP ANGLE CALCULATION OF THE ELECTRONIC STABILITY CONTROL (ESC) SYSTEM. THIS MIGHT CAUSE THE ESC TO PERCEIVE AN OVER STEERING SITUATION AND THEREFORE APPLY THE OUTER WHEEL BRAKE ON THE FRONT AXLE UNTIL THE VEHICLE IS PERCEIVED TO BE STABLE.

MOTOR COACH INDUSTRIES, INC. (MCI) IS RECALLING CERTAIN MODEL YEAR 2011 E4500 AND J4500 MOTOR COACHES MANUFACTURED FROM DECEMBER 2010 THROUGH JANUARY 2011, EQUIPPED WITH A CUMMINS ISX 11.9 DIESEL ENGINE. THE V-BAND CLAMP ASSEMBLY, PART NUMBERS Q187684, Q187685, AND Q187686, USED TO CONNECT THE INLET AND OUTLET CONE SECTIONS TO THE DIESEL OXIDATION CATALYST (DOC)/DIESEL PARTICULATE FILTER (DPF) INCLUDE A T-BOLT WHICH CAN FRACTURE AND FAIL WHEN SUBJECTED TO STRESS OR LOAD. A FRACTURE OR FAILURE OF THE T-BOLT MAY CAUSE THE CLAMP TO LOOSEN AND THE INLET OR OUTLET SECTIONS ATTACHED TO THE DOC/DPF HOUSING TO DISCONNECT.

MCI IS RECALLING CERTAIN MODEL YEAR 2011 MCI E4500, AND J4500, MOTOR COACHES MANUFACTURED FROM SEPTEMBER 2010 THROUGH JULY 2011, EQUIPPED WITH A DOGA WINDSHIELD WIPER MOTOR. AN UNDERRATED FUSE MAY HAVE BEEN INSTALLED AT THE FACTORY, WHICH COULD BLOW, RESULTING IN THE WINDSHIELD WIPERS NOT OPERATING.

MCI IS RECALLING CERTAIN MODEL YEAR 2011 MCI J4500, E4500, AND J4500C MOTOR COACHES MANUFACTURED FROM MAY 1, 2010 THROUGH JANUARY 31, 2011, AND EQUIPPED WITH DOGA WINDSHIELD WIPERS. CERTAIN WIRES MAY HAVE BEEN INCORRECTLY INSTALLED BY MCI AT THE FACTORY WHICH COULD RESULT IN THE WINDSHIELD WIPERS FAILING TO OPERATE.

MCI IS RECALLING CERTAIN MODEL YEAR 2001-2004 E4500, MODEL YEAR 2002-2006 E4500C, MODEL YEAR 2001-2005 J4500, AND MODEL YEAR 2006 J4500C MOTOR COACHES EQUIPPED WITH SE-GI PASSENGER WINDOWS. THE ADHESIVE BOND BETWEEN THE WINDOW GLASS AND THE ALUMINUM WINDOW FRAME ON THE AFFECTED COACHES MAY DEGRADE.

MCI IS RECALLING CERTAIN MODEL YEAR 2010 D4000, D4005, D4500, D4505, E4500, AND J4500 MODEL MOTOR COACHES MANUFACTURED FROM SEPTEMBER 2009 THROUGH MAY 2010, EQUIPPED WITH ARVINMERITOR FRONT AND TAG AXLE ASSEMBLIES. THE SUSPECT AXLES MAY HAVE HAD IMPROPER TORQUE APPLIED TO THE HUB/ROTOR/WHEEL ADAPTER BOLTS DURING THE ASSEMBLY PROCESS. REDUCED BOLT TORQUE COULD LEAD TO VIBRATION LOOSENING OF THE BOLT.